8.11 Jointers
8.11.1 Jointers may be furnished if agreed. 8.11.2 Welded jointers shall be made in accordance with the requirements of Annex A. 8.11.3 No pipe used in making a jointer shall be less than 1,5 m (5.0 ft) long.
8.13 Traceability
8.13.1 For PSL 1 pipe, the manufacturer shall establish and follow documented procedures for maintaining a) b) the heat identity until all related chemical tests are performed and conformance with the specified requirements is shown, the test-unit identity until all related mechanical tests are performed and conformance with the specified requirements is shown.
8.13.2 For PSL 2 pipe, the manufacturer shall establish and follow documented procedures for maintaining the heat identity and the test-unit identity for all such pipe. Such procedures shall provide means for tracing any length of pipe to the proper test unit and the related chemical and mechanical test results.
9
9.1
Acceptance criteria
General
The general technical delivery requirements shall be in accordance with ISO 404.
9.1.1
9.1.2 Pipe manufactured as Grade L415 or X60 or higher shall not be substituted for pipe ordered as Grade L360 or X52 or a lower grade, without the purchaser's approval.
--`,,,```,,,,,````````,,```,``-`-`,,`,,`,`,,`---
22