(Metric Units)
(Re = 66.4 DV)
where: D = duct diameter, inches (mm) V = duct velocity, fpm (m/s) For Rectangular Ducts:
14.19
DUCT
DESIGN
TABLES
AND
CHARTS
Table 14-10 LOSS COEFFICIENTS, ELBOWS (Cont.) Use the velocity pressure (Vp) of the upstream section. Fitting loss (TP) = C x Vp D. Elbow, Rectangular, Mitered (15)
where: D = duct diameter, inches (mm) V = duct velocity, fpm (m/s) For Rectangular Ducts:
14.20
CHAPTER 14
Table 14-10 LOSS COEFFICIENTS, ELBOWS (Cont.) Use the velocity pressure (Vp)of the upstream section. Fitting loss (TP) = C x Vp G. Elbow, Rectangular, Smooth Radius with Splitter Vanes (2)
NOTES FOR THIS FIGURE ONLY: A) See Page 5.14 to calculate splitter vane spacing.
B) CR = Curve Ratio
C) Use correction factors in Note 1 on Page 14.19 for elbows other than 90.
14.21