Consultant
Telford & Wrekin Council
Client
TDR Mechanical Limited
Sector
Education
Front Entrance
Products
MasterFlue System
Equipment
Hamworthy PV105c
Airtherm Masterflue
Application
Condensing
Airtherm Engineering Limited has recently completed a flue installation, working closely with the contractor at Addensbrooke House, Telford, Shropshire. The flue system(s) selected is that used Masterflue by Hamworthy Heating on their own boiler range. The flue system installed is serving four new high efficiency condensing boilers, and the flue system comprises of a twin wall stainless stel inner & outer casing with 25mm insulation. The flue system has a 3.5m horizontal run and a 2.5m vertical, incorporating the necessary drains to allow any unwanted condense to evacuate the system. Also in the same plant room is a Hamworthy DR-LA 75 water heater which Airtherm has supplied and installed a twin wall stainless steel flue system from the appliance to termination. Both systems complying with BS & Clean Air Act Memorandum.
Product Solution
Airtherm Masterflue
Hanmworthy Modumax Variheat PV105 Chimney / Flue system Wet Negative / positive pressure
Working pressure: 200 Pa (product will operate 1000pa max) Inner wall: Outer wall: Insulation: Sealant : Fuel type: 316L1.4404/1.457 thickness 300 0,5 mm AISI 304/ 1.4301 thickness 0,5 / 0,6 mm 25mm thick Rockwool insulation tri-lip 'o' type silicone ring Gas
MasterFlue
Contact Details:
Airtherm Engineering Ltd Ventilation House Pedmore Stoubridge West Midlands DY9 0DS Tel: 0844 8092509 Fax: 01562 887312