HA3
NOTICE: The manufacturer will accept no responsibility for any electrical damage resulting from improper installation of this product, be that either damage to the vehicle itself or to the installed device. This device must be installed by a certied technician. This guide has been written for properly trained technicians; a certain level of skill & knowledge is therefore assumed. Please review the Installation Guide carefully before beginning any work.
Page 2 of 8
ADS-AL(DL)-HA3-EN
20130305
TRUNK/HATCH RELEASE*
TACHOMETER OUTPUT
POWER LIFTGATE*
ACURA
TL STD key TSX STD key ZDX STD key Accord STD key Accord Crosstour STD key
HONDA
Civic STD key Civic Hybrid STD key CR-V STD key Odyssey STD key
Pilot STD key 09-13 1 * When vehicle is remote started, feature will not be functional. Use traditional hardwired installation method for feature to be functional during remote start.
www.idatalink.com/support
E-BRAKE OUTPUT
DOOR UNLOCK
INSTALL TYPE
DOOR LOCK
MODEL
MAKE
YEAR
Page 3 of 8
ADS-AL(DL)-HA3-EN
20130305
XX-XX ADS-AL(DL)-HA3 T1
I Ground When Running from Remote Starter must be provided BEFORE Ignition. Failure to comply may result in immobilizer bypass malfunction during remote start. II III - DO NOT program unlock before start on the Remote Starter. - DO NOT change Remote Starter OEM alarm control default settings. Failure to comply may result in product malfunction.
IMPORTANT
If Ground When Running from Remote Starter CANT be provided BEFORE Ignition, use a separate TB-HA for immobilizer bypass ONLY.
PAGE X-X
Ignition TL STD key 09-13 Key Data CanH CanL Ignition ACURA TSX STD key 09-13 Key Data CanH CanL Ignition ZDX STD key 10-11 Key Data CanH CanL Ignition Accord STD key 08-12 Key Data CanH CanL Ignition Accord Crosstour STD key 10-12 Key Data CanH CanL Ignition Odyssey STD key 11-13 Key Data CanH CanL Ignition Pilot STD key 09-13 Key Data CanH CanL
~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~
White White White White White White White White White White White White White White White White White White White White White White White White White White White White
7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin 7 pin
2 6 4 3 2 6 4 3 2 6 4 3 2 6 4 3 2 6 4 3 2 6 4 3 2 6 4 3
Yellow LtGreen Pink Blue Yellow LtGreen Pink Blue Yellow LtGreen Pink Blue Yellow LtGreen Pink Blue Yellow LtGreen Pink Blue Yellow Purple Pink Blue Brown Pink White LtGreen
(+) (DATA) (DATA) (DATA) (+) (DATA) (DATA) (DATA) (+) (DATA) (DATA) (DATA) (+) (DATA) (DATA) (DATA) (+) (DATA) (DATA) (DATA) (+) (DATA) (DATA) (DATA) (+) (DATA) (DATA) (DATA)
HONDA
www.idatalink.com/support
MODULE LOCATION At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer At immobilizer
POLARITY
POSITION
MODEL
COLOR
WIRE COLOR
NAME
MAKE
YEAR
TYPE
install guide
Guides Franais disponibles au www.idatalink.com
ALL IN ONE
Honda/Acura
ADS-AL(DL)-HA3-EN
Page 4 of 8
20130305
<- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED
BRAKE (+) INPUT HOOD STATUS (-) INPUT TRUNK STATUS (-) INPUT DOOR STATUS (-) INPUT
CONNECT TO DRIVER DOOR PIN TO TURN OFF HEADLAMP ON VEHICLES EQUIPPED WITH AUTOMATIC HEADLAMP
GWR (-) INPUT - BLUE/WHITE (NC) NO WIRE GROUND - BLACK 12V (+) - RED LOCK/ARM (-) INPUT - GREEN/BLACK UNLOCK (-) INPUT - BLUE/BLACK TRUNK/LIFTGATE (-) INPUT - RED/WHITE DISARM (-) INPUT - BROWN LEFT SLIDING DOOR (-) INPUT - PURPLE/YELLOW 2 POSSIBLE APPLICATIONS - PURPLE/BLACK (NC) WHITE STARTER (+) INPUT - BLACK/WHITE E-BRAKE STATUS (-) OUTPUT - GREEN TACH (AC) OUTPUT - PURPLE/WHITE
RIGHT SLIDING DOOR (-) INPUT OR TAILGATE WINDOW (-) INPUT
WHITE/BLACK (-) OUTPUT WHITE/RED (NC) WHITE - GROUND (-) YELLOW/BLACK - DOOR STATUS (-) OUTPUT YELLOW/RED - TRUNK STATUS (-) OUTPUT YELLOW - HOOD STATUS (-) OUTPUT* BROWN/RED - CANH BROWN/YELLOW - CANL ORANGE/BLACK - KEY DATA ORANGE/WHITE (NC) ORANGE (NC) PINK/BLACK (NC) PINK - IGNITION (+) INPUT BLUE/RED (NC) BLUE/YELLOW (NC) GREEN/RED (NC) GREEN/YELLOW (NC) GRAY/RED - BRAKE (+) OUTPUT GRAY/YELLOW (NC)
IG NI T CA IO NL N ( +) CA NH
NOTE SINCE THE MODULE INCLUDES A DISARM INPUT FEATURE, BOTH UNLOCK BEFORE START AND LOCK AFTER START FEATURES ARE NOT REQUIRED. 1
www.idatalink.com/support
DA T
Page 5 of 8
ADS-AL(DL)-HA3-EN
20130305
Ignition Civic/ Civic Hybrid STD key HONDA CanH 12-13 CanL Key Data Lock Unlock Ignition CanH CR-V STD key 12-13 CanL Key Data Lock
~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~
2 4 3 6 ~ ~ 2 4 3 6 ~
Yellow Pink Blue LtGreen Blue* Gray DkBlue Pink Blue Yellow Green
(+) (DATA) (DATA) (DATA) (-) (-) (+) (DATA) (DATA) (DATA) (-) (-)
Unlock ~ ~ ~ ~ Gray *WARNING: Failure to test this wire will damage the module. Wire gage may be smaller.
www.idatalink.com/support
MODULE LOCATION Ignition switch Ignition switch Ignition switch Ignition switch Driver door harness Driver door harness Ignition switch Ignition switch Ignition switch Ignition switch Driver door harness Driver door harness
POLARITY
POSITION
MODEL
COLOR
WIRE COLOR
NAME
MAKE
YEAR
TYPE
install guide
Guides Franais disponibles au www.idatalink.com
ALL IN ONE
Honda/Acura
ADS-AL(DL)-HA3-EN
Page 6 of 8
20130305
) (CK -) ( LO CK LO
UN
<- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED <- REQUIRED
BRAKE STATUS (+) INPUT HOOD STATUS (-) INPUT TRUNK STATUS (-) INPUT DOOR STATUS (-) INPUT
LEGEND NOT REQUIRED IN DATA MODE (1-WAY) NOT REQUIRED IN DATA MODE (2-WAY) USE DATA MODE OR HARDWIRE MODE DATA MODE
GWR (-) INPUT - BLUE/WHITE (NC) NO WIRE GROUND - BLACK 12V (+) - RED LOCK/ARM (-) INPUT - GREEN/BLACK UNLOCK (-) INPUT - BLUE/BLACK TRUNK (-) INPUT - RED/WHITE DISARM (-) INPUT - BROWN GROUND (-) INPUT - PURPLE/YELLOW (NC) PURPLE/BLACK (NC) WHITE STARTER (+) INPUT - BLACK/WHITE E-BRAKE STATUS (-) OUTPUT - GREEN TACH (AC) OUTPUT - PURPLE/WHITE
CONNECT TO GROUND TO ENABLE AUTOMATIC RELOCK AFTER START
WHITE/BLACK WHITE/RED - UNLOCK (-) WHITE - LOCK (-) YELLOW/BLACK - DOOR STATUS (-) OUTPUT YELLOW/RED - TRUNK STATUS (-) OUTPUT YELLOW - HOOD STATUS (-) OUTPUT BROWN/RED - CANH BROWN/YELLOW - CANL ORANGE/BLACK - KEY DATA ORANGE/WHITE (NC) ORANGE (NC) PINK/BLACK (NC) PINK - IGNITION (+) INPUT BLUE/RED - GROUND (-) INPUT BLUE/YELLOW - DOORLOCK GREEN/RED (NC) GREEN/YELLOW (NC) GRAY/RED - BRAKE STATUS (+) OUTPUT GRAY/YELLOW (NC)
IG NI CA TIO N N( +) CA L NH
www.idatalink.com/support
KE
7
DA T
install guide
Guides Franais disponibles au www.idatalink.com
ALL IN ONE
Honda/Acura
ADS-AL(DL)-HA3-EN
Page 7 of 8
20130305
Press and hold programming button until LED turns solid GREEN to register selection. After registration, follow Factory Reset Procedure to change installation mode and restart this procedure.
LED ashes (1X) once = DATA MODE LED ashes (2X) twice = STANDARD HARDWIRE MODE
!
4 5
1 2
ON
OFF
x1
!
6
If the vehicle is equipped with a power liftgate: Open and close the power liftgate with the OEM keyfob.
www.idatalink.com/support
Page 8 of 8
20130305
Locate the Vehicle Identication Number (VIN) and identify the 10th character.
2
L > 1990 S > 1995 T > 1996 V > 1997 W > 1998 X > 1999 M > 1991 N > 1992 P > 1993 R > 1994
Y > 2000 1 > 2001 2 > 2002 3 > 2003 4 > 2004
5 > 2005 6 > 2006 7 > 2007 8 > 2008 9 > 2009
A > 2010 B > 2011 C > 2012 D > 2013 E > 2014
43A5Y1N5TAL8D5R0X
MODULe DiAgnOStiCS
LED STATUS Flashing RED Solid RED Flashing GREEN Solid GREEN then OFF OFF DIAGNOSTICS DURING PROGRAMMING Missing/wrong information from rmware or vehicle Waiting for more vehicle information Additional steps required to complete programming Correctly programmed No activity or already programmed DURING REMOTE START Incorrectly programmed Incorrectly programmed Correctly programmed and operational Reset in progress Invalid ground when running status from remote starter WITH IGNITION OFF Incorrectly programmed or connected Not programmed waiting for more vehicle information False ground when running status from remote starter Reset in progress At rest and ready for a remote start sequence
1 2
DISCONNECT all connectors from module EXCEPT the black 4-PIN standard or optional data connector.
5 6 7
LED will turn solid red for 2 seconds. RESET COMPLETED. RECONNECT all connectors.
3 4
PRESS AND HOLD programming button while connecting either 4-PIN standard or optional data connector.
Failure to follow procedure may result with a DTC or a CHECK ENGINE error message.
www.idatalink.com/support