Microcontroller Manufacturer: NXP (founded by Philips) Evaluation Board Manufacturer: Keil Processor Type: ARM7 NXP LPC2378 Evaluation Board features:
2 Serial interfaces Speaker Analog Input (via potentiometer) 2 CAN (controller area network) interfaces LCD USB Ethernet 8 LEDs
Processor Specifications:
512KB on-chip Flash ROM 58KB RAM CPU clock up to 72 MHz Ethernet External Memory Controller for static devices such as Flash and SRAM USB 2.0 Full Speed Device Controller CAN 2.0B with two channels SD/MMC memory-card interface 10-bit ADC with 8 channels 10-bit DAC PWM unit for three-phase motor control General purpose I/O pins
CAN bus (controller area network) is a vehicle bus standard designed to allow microcontrollers and devices to communicate with each other within a vehicle without a host computer.
The Keil ULINK2 Debug Adapter connects your PC's USB port to your target system JTAG and allows you to program and debug embedded programs on target hardware.
Supports various ARM7, ARM9, Cortex-M, 8051, and C166 devices JTAG speed up to 10MHz Seamless integration with the Keil Vision IDE & Debugger Wide target voltage range: 2.7V - 5.5V USB powered (no power supply required) Plug-and-Play installation using standard windows USB drivers Target Connector
20-pin (0.10") - ARM Standard JTAG Connector
Joint Test Action Group (JTAG) is the common name for the IEEE 1149.1 Standard Test Access Port and Boundary-Scan Architecture.