0 penilaian0% menganggap dokumen ini bermanfaat (0 suara)
42 tayangan1 halaman
The document provides instructions for calculating the combined center of gravity of a loaded railcar. It defines the key terms needed for the calculation, including the height and center of gravity measurements for the empty railcar and load. An example calculation is shown that combines the weight and center of gravity measurements for a railcar and load to determine the overall center of gravity above the top of rail. Notes explain that more complex calculations are needed if a load has multiple pieces with different centers of gravity and that acceptable centers of gravity are defined in AAR interchange rules.
The document provides instructions for calculating the combined center of gravity of a loaded railcar. It defines the key terms needed for the calculation, including the height and center of gravity measurements for the empty railcar and load. An example calculation is shown that combines the weight and center of gravity measurements for a railcar and load to determine the overall center of gravity above the top of rail. Notes explain that more complex calculations are needed if a load has multiple pieces with different centers of gravity and that acceptable centers of gravity are defined in AAR interchange rules.
The document provides instructions for calculating the combined center of gravity of a loaded railcar. It defines the key terms needed for the calculation, including the height and center of gravity measurements for the empty railcar and load. An example calculation is shown that combines the weight and center of gravity measurements for a railcar and load to determine the overall center of gravity above the top of rail. Notes explain that more complex calculations are needed if a load has multiple pieces with different centers of gravity and that acceptable centers of gravity are defined in AAR interchange rules.
CENTER OF GRAVITY - RAILCAR MOVEMENTS PROCEDURES FOR DETERMINING COMBINED CENTER OF GRAVITY OF LOAD ON CAR ABOVE TOP OF RAIL OF LOADED OPEN TOP CARS AND BOXCARS. The following information is necessary to determine the combined center of gravity of a loaded railcar. A = Height of car deck in inches from top of rail. (Stenciled on railcar - only source.) B = Center of gravity of empty railcar above top of rail in inches. (Stenciled on railcar - only source.) C = Center of gravity of load from base of load in inches. (Shipper furnishes.) D = Combined height of center of gravity of load, (C), plus height of car deck, (A), that is (C) + (A). E = Light or tare weight of railcar, in pounds. (Stenciled on railcar and in Umler.) F = Weight of load in pounds. (Shipper furnishes.) The calulation to arrive at the center of gravity is as follows: (B x E) + (D x F) = C.G. ATR E + F Example: A = 44 inches B = 27 inches C = 60 inches D =(60 + 44) = 104 inches E = 55,000 Lbs. F = 120,000 Lbs. Formula: (B x E + (104 x 120,000) E + F (27 x 55,000) + (104 x 120,000) 55,000 + 120,000 1,485,000 + 12,480,000 = 13,965,000 = 79.8 inches ATR 175,000 175,000 Notes: 1. The above is an example of a basic calculation for determining the combined center of gravity Of load and car. 2. Where the load consists of multiple piles or pieces with differing centers of gravity, the entire C.G. of the entire load must be calculated before it is combined with car weight & C.G. 3. Acceptable centers of gravity for interchange purposes are governed by Rule 89, Section B, 1, e of the AAR Interchange Rules. B D C A