Anda di halaman 1dari 3

ELG 3336

PRE LABORATORY 1
Inverting Operational Amplifier




Presented to
Mahmud Hasan





By
Justin Lefebvre 6832573






15 September 2014
University of Ottawa

The objective of this pre lab is to use the software multisim to reproduce the circuits and data
that will be seen in the actual experiment. The following circuit was produced in the software
that includes two resistors and one Op Amp. The function generator which is branched in circuit
while the Oscilloscope in paralleled to measure the current and voltage thought each element.


Circuit


The following images are what the oscilloscope read from the resistor followed by the capacitor.
What was found using ohms law and the data was running through the resistor was 7 mV and 1.4 mV at
the varying frequencys and pin voltages.









Oscillator scope reading at 100 Hz and 15 V

Oscillator scope reading at 100 KHz and 15 V

Anda mungkin juga menyukai