Anda di halaman 1dari 4

11/10/2014

Help: To Finish the Part

To Finish the Part

LIKE (0)

SHARE

For the last finishing operation, use another Pencil finishing toolpath over the entire part except the base surface. Copy the previous operation
and edit the parameters.
1. Right-click on the Pencil1 operation in the CAM Browser.
2. Select Copy from the pop-up context menu.
3. Right-click again and select Paste from the context menu. A copied operation Copy of Pencil1 is added to the bottom of the list of
toolpaths.
4. Rename the copied toolpath to Parallel Pencil.
5. Right-click Parallel Pencil and select Edit from the context menu to open the Operation dialog box and edit the parameters.

Tool tab
The selected tool should still be #21 - 6mm ball.

Geometry tab
Confine the toolpath to the area above the base.
1. Click the Geometry tab.
2. From the Machining boundary: drop-down menu, choose Selection.
3. Select an edge on the lower boundary as shown below:

4. Set Additional offset: to: 1 mm

Passes tab
1. Click the Passes tab.
2. Disable the Limit number of stepovers check box.
3. Set Stepover: to: 0.7 mm
4. Disable the Stock to Leave check box.

Start the Calculation


1. Click
at the bottom of the Operation dialog box, or right-click in the graphics window and select OK from the marking menu,
to automatically start calculating the toolpath.
The toolpath is now calculated and a preview appears in the graphics window.

http://help.autodesk.com/view/INVHSM/2015/ENU/?guid=GUID-776DE7BD-DBF4-465E-BB28-3F08E0DDD485

1/4

11/10/2014

Help: To Finish the Part

That completes the toolpaths for this tutorial. You should now have these operations listed in the CAM Browser:

Continue to To Post Process the Part (Tutorial 4)...


Parent topic: Tutorial 4 - High-Speed 3D Machining

Was this Article Helpful?


Please help us improve the content on this site. Was this article helpful?

Yes

No

http://help.autodesk.com/view/INVHSM/2015/ENU/?guid=GUID-776DE7BD-DBF4-465E-BB28-3F08E0DDD485

2/4

11/10/2014

Help: To Finish the Part

http://help.autodesk.com/view/INVHSM/2015/ENU/?guid=GUID-776DE7BD-DBF4-465E-BB28-3F08E0DDD485

3/4

11/10/2014

Help: To Finish the Part

http://help.autodesk.com/view/INVHSM/2015/ENU/?guid=GUID-776DE7BD-DBF4-465E-BB28-3F08E0DDD485

4/4

Anda mungkin juga menyukai