(Saefudin)
ABSTRACT
To provide good black pepper cuttings grown in polythene bags, it might be costly due to transportation cost should be covered into cost production.
The use of rooted cuttings of black pepper is therefore considered as an alternative solution in providing of plant materials being ready to be planted in
the fields. A research was carried out at a glass house of Sukamulya Research Station (Sukabumi) from January to Desember 2011. The objective of
the study was to investigate the effects of age and storage periods of rooted cuttings on their freshness and growth performances under nursery
condition. A randomized factorial design with three replications was used. The age of black pepper cuttings consisted of 1, 2, and 3 months old, while
the storage periods were 0, 3, 5, 7 and 9 days. The number of pepper cuttings observed for their freshness levels were 50 cuttings per treatments,
whereas those of their growth were 25 cuttings. For evaluation of their freshness, they were calculated based on the percentage of treated cuttings
having water content of higher than 75%, while for their growth parameters observed were height of rooted cuttings, number of nudes, leaf length,
leaf width, and length of internodes. The data were then analyzed with analysis of variance (anova) followed by HSD test level 5%. The results
showed that there were noted interaction between the age and storage periods of rooted cuttings to the freshness and growth of young rooted cuttings.
If farmers use rooted cuttings taken out from their polythene bags, then 2-month cutting olds with maximum storage periods of 5 days would give the
best treated rooted cuttings having high in performance growth.
Keywords: Black pepper, age, storage, cuttings, growth
245
PENDAHULUAN
Tanaman lada merupakan komoditas
penting yang memiliki nilai ekonomi tinggi bagi
rakyat Indonesia. Produktivitas rata-rata tanaman
lada Indonesia 0,7-0,75 ton/ha, jauh lebih rendah
dibandingkan produktivitas tanaman lada negaranegara pesaing seperti Vietnam yang sudah
mencapai 2-3 ton/ha, Brazil 1,4 ton/ha, Malaysia
1,69 ton/ha dan China 1,29 ton/ha (Wahyudi,
2010). Salah satu penyebab rendahnya
produktivitas tanaman dan mutu produk lada
Indonesia adalah belum digunakannya benih unggul
bermutu (Karmawati dan Supriadi, 2007; Kemala
dan Karmawati, 2007).
Benih bermutu yang berasal dari varietas
unggul merupakan salah satu inovasi yang paling
handal untuk meningkatkan produktivitas lada, baik
dari potensi maupun toleransinya terhadap
cekaman biotik dan abiotik (Wahyudi, 2010).
Daya tarik utama benih unggul adalah
produktivitasnya lebih tinggi dari benih yang
selama ini digunakan petani yang sebagian besar
masih menggunakan benih asalan. Sudjarmoko
(2010) menyebutkan bahwa penggunaan benih
unggul menjadi salah satu kunci dalam
meningkatkan produktivitas tanaman dan
pendapatan petani. Hadad dan Ferry (2011)
menambahkan, bahwa penggunaan benih unggul
bermutu merupakan 60% jaminan keberhasilan
usaha perkebunan.
Beberapa varietas unggul tanaman lada
telah ditemukan yaitu Natar 1, Natar 2, Petaling1,
Petaling 2, Chunuk, Bengkayang dan LDK, dengan
potensi produksi yang cukup tinggi 1,974,48
ton/ha/th (Nuryani dan Mustika, 1985; Hamid et
al., 1991; Zaubin et al., 1992).
Perbanyakan tanaman lada umum
dilakukan secara vegetatif dengan setek karena
lebih praktis, efisien dan benih yang dihasilkan
sama dengan sifat induknya. Perbanyakan vegetatif
dengan Somatic Embryogenesis (SE) masih dalam
tahap penelitian sehingga masih perlu waktu untuk
dapat diaplikasikan di tingkat petani (Meynarti et
al., 2011).
Teknologi hasil penelitian perbenihan lada
pada berbagai aspek telah ditemukan, seperti:
ketinggian penyetekan pada pohon induk,
penggunaan setek satu ruas, penyungkupan,
246
247
Jumlah ruas
Lingkar
batang
(cm)
3,06 a
2,71 a
3,01 a
2,85 a
2,90 a
2,73 a
2,89 a
3,24 a
3,13 a
2,69 a
2,67 a
16,7
2,55 a
2,73 a
2,97 a
2,74 a
3,14 a
19,5
Keterangan : Angka yang diikuti huruf yang sama pada setiap kolom menunjukkan tidak berbeda nyata pada taraf 5 %
Notes
: Numbers followed the same letters on each column are not significantly different at 5% level
249
250