Class Ring
1. Use the Tapered Square Shank to get started. 6mm top thickness,
2mm bottom thickness, 18mm top width, and 8mm bottom width.
2. Draw a 20mm wide rectangle and center it above the silhouette. Use
it as a guideline to create a flat top for the class ring.
6. The quickest way to draw the side panel borders is to draw a single
edge, mirror it, join and close with straight lines. Then mirror to the
other side of the ring.
9. Putting a .1mm bevel on your lettering maes it stand out more. Use
the shape editor with a pyramid limited to .1mm.
11. Then select all the remaining vectors and unselect the outer vector and apply the
shape editor again. 20 degree round and a start height of .1mm.
13. Add a bezel set stone in a 90 degree bezel using the Rotary Flush Setting Tool.
Select position on ring.