Test GNSS
Test GNSS
III.
Survey site must be identified with 3G connection or phone coverage such as celcom,
maxis or digi.
II.
Two (2) minimum GPS receivers needed to conduct these survey activities.
III.
One of receivers is set to be a rover while another one is set as base receiver.
IV.
In order to receive MyRTKnet corrections, users need to have a GPS rover system, which
should consist of the following:
V.
The GPS equipment then are connected to DSMM(JUPEM) server as MyRTKnet system
need to be run for real-time kinematic observation take place.
VI.
When RTK are fixed, survey work can be conducted either for cadastral or engineering
scope.
VII.
The rover is moved from one point to another while base receiver in static mode. The
rover take an action to give new data for every point moved.
VIII.
For cadastral survey, rover is set up at loop traverse station to observe coordinate, bearing
and distance.
IX.
For topography survey (engineering), rover take an action as pickup pole to observe
coordinate and elevation of certain point.
X.
After survey work done, surveyor must disconnected the receivers with linked server.