6BQ5-8BQ5
PENTODE
ll FOR AF POWER AMPLIFIER APPLICATIONS
DESCRIPTION AND RATING:
‘The 6BQS is a power-amplifier pentode designed for use in the audio-fre-
quency power-output stage of television and radio receivers and in high-fidelity
amplifiers.
Except for heater ratings, the 8BQ5 is identical to the 6BQ5.
GENERAL
ELECTRICAL
Gsthode Coated Unipotentat 6BQ5-BQS
Heater Voltage, AC or DC. 63 80 Volts
Heater Current.
1076 0.6 Amperes
ve 11 Seconds
Heater Warm-up Time*.
Direct interelectrode Capac
ancest
Grid-Number 1 to Plate, maximum. . pak
Input Bebe at
ipl eae ene Eee nnaia wat
MECHANICAL
Mounting Position—Any
Envelope—T-6¥%2, Glass
Base—E9-1, Smail Button 9-Pin
MAXIMUM RATINGS
DESIGN-CENTER VALUES
Plate Voltage Volts
Screen Voltage - Volts
Negative DC Grid-Number T Voltage. . Volts
Plate Dissipation Watts
Screen Dissipation (Continuous)... - Watts
Screen Dissipation (Peaks of Speech ond M Watts
DC Cathode Current Milliamperes
Heater-Cathode Voltag
Heater Pi with Respect to Cathode - 100 Volts
Heater Negative with Respect to Cathode... .......-100 Volts
Grid-Number 1 Circuit Resistance
With Fixed Bias 0.3. Megohms
With Cathode Bias. . 1,0 Megohms
Design-Center ratings are limiting values of operating conditions applicable to a
bogey tube of a specified type as defined by its published data, and should not be
exceeded under normal conditions.
The tube manufacturer chooses these values to provide acceptable serviceability
of the tube in average applications, taking responsibility for normal changes in
operating conditions due to rated supply voltage variation (For an AC power sour
117 volts plus or minus 10% is accepted USA practice.), equipment component vari
tion, equipment control adjustment, load variation, signal variation, environmental
conditions, and variations in tube characteristics.
The equipment manufacturer should design so that initially no design-center value
for the intended service is exceeded with a bogey tube in equipment operating at
the stated normal supply voltage.
fehl feoon insur ag ou FS tae
GENERAL @@ ELECTRIC
6BQ5
8BQ5
ET-T1535,
Page |
S59
BASING DIAGRAM
TERMINAL CONNECTIONS
Pin 1—Internal Connection
Pin 2—Grid Number 1
Pin 3—Cathode and Grid
Number 3 (Suppressor)
Pin 4d—Heater
Pin 5—Heater
Pin 6—Internal Connection
Pin 7—Plate
Pin 8—Internal Connection
Pin9—Grid Number 2
(Screen)
PHYSICAL DIMENSIONS6BQ5
ET-T1535
Page 2
357
CHARACTERISTICS AND TYPICAL OPERATION
AVERAGE CHARACTERISTICS
Plate Voltage.
Screen Voltage.
Grid-Number 1 Voltage. -
Plate Resistance, approximat
Transconductance.....-.+
Plate Current,
Screen Current.
Amplification Factor (Grid-Number 1 to Grid-Number 2). -
CLASS A, AMPLIFIER
Plate Voltage
Screen Voltage
250 250-250 Volts
250 250 +210 Volts
Grid-Number 1 Voltage. . -73 -84 64 Volts
Peck AF Grid-Number 1 Voltage 62 495 48 Volts
Zero-Signal Plate Current... 4B 36 36 Milliamperes
wum-Signal Plate Current... 506 368 36.6 Milliomperes
Signal Screen Current 55 Ad 39° Milliamperes
Maximum-Signal Screen Current... 10 85 7.3. Milliamperes
Load Resistance 4500 7000 7000 Ohms
Total Harm 10 10 10. Percent
‘Maximum-Signal Power Output. . 57 4243 Watts
PUSH-PULL CLASS AB, AMPLIFIER, VALUES FOR TWO TUBES
Plate Voltage. .
Screen Voltage
Cathode-Bias Re
Peak AF Grid-to-Grid Voltage
250 300 Volts
1.250 300 Volts
222130130 Ohms
226 (282
Zero-Signal Plate Current. 62 72
Maximum-Signal Plate Current 75 2
Zero-Signal Screen Current... 70 80
Maximum-Signal Screen Current. 15 22
Effective Load Resistance, Plate-to-Plate 2000 8000
Total Harmonic Distortion... . 3 4 Percent
‘Maximum-Signal Power Output SS u 17 Watts
PUSH-PULL CLASS B AMPLIFIER, VALUES FOR TWO TUBES
Plate Voltage. . cee .
Sereen Voltage. .- :
Grid-Number 1 Voltage.
Peak AF Grid-to-Grid Voltage
250 300 Volts
pang 250 300 Volts
severe 16 =147
22.6 28.2
ignal Plate Current... = 20 15
um-Signal Plate Current 75 92
jignal Screen Current 2.2 16
Maximum-Signal Screen Current 15 22
Effective Load Resistance, Plate-to-Plate.
Total Harmonic Distortion 5
Maximum-Signal Power Output. -
CLASS A; AMPLIFIER, TRIODE CONNECTIONS
Plate Voltage. Volts
Cothode-Bias Resist Ohms
Peak AF Grid-Number 1 Voltage Volts
Zero-Signal Plate Current Milliamperes
‘Maximum-Signal Plate Current. Milliamperes
Load Resistance : Ohms
Total Harmonic Distortion, approximate 5 Percent
Maximum-Signal Power Output. . 5 Watts6BQ5
ET-T1535
Page 3
39
CHARACTERISTICS AND TYPICAL OPERATION (Continued)
PUSH-PULL CLASS AB, AMPLIFIER TRIODE CONNECTION, VALUES FOR TWO TUBESt
Plate Voltage 7
Cathode-Bias Resistor... .
Peak AF Grid-to-Grid Voltage... ...- +++
Zero-Signal Plate Current... .
Effect
Total Harmonic Distortion...
Maximum-Signal Power Output...
250 300 Volts
‘i ‘270 270 Ohms
ceseessss23.4 28.2 Volts
. 5 40 48 mperes
wum-Signal Plate Current we ween eee ABA 52 mperes
/e Load Resistance, Plate-t seetesessssssssssss10000 10000 Ohms
cevesesseee:25 25° Percent
34 52 Watts
* The time required for the voltage across the heater to reach 80 percent of its rated value atter applying 4 times rated
heater
voltage to a circuit consisting of the tube heater in series with a resistance equal to 3 times the rated heater
voltage divided by the rated heater current.
t Without external shield,
+ With screen tied to plate,
URRENT IN WILLIAMPERES.
PLATE
AVERAGE PLATE CHARACTERISTICS
TRIODE CONNECTION
330
€¢ = RATED VALUE
300 SCREEN TIED TO PLATE
250
290
100
50
° 100 200 300 400 500
Kasse! (-T052+1 ce oeceuoen 25, 19586BQ5
ET-T1535
Poge 4 AVERAGE PLATE CHARACTERISTICS
200 30
Ey = RATED VALUE
fez * 250 VOLTS
40
2150
5 30
Bio0)
PLATE
° 400 200 300 400 500
PLATE VOLTAGE IN VOLTS
K-55611-7052-2 becemBeR 17, 1958
AVERAGE TRANSFER CHARACTERISTICS a
Ta: Tae
— 120
Ef = RATED VALUE
250 voUTS
20
20 15 =10 “3 °
K-55611-T052-3, Re DECEMBER 25, 1988
es
SCREEN CURRENT (leg) IN MILLIAUPER
10
PLATE CURRENT IN MILLIANPERESPOWER OUTPUT IN WATTS
TOTAL HARMONIC DISTORTION IN PERCENT
AVERAGE TRANSFER CHARACTERISTICS
Ey = RATED VALUE
250 voLTS
fp
-20
Kobb6 I I-T08z—4
29,
=15
Ey = RATED VALUE
24
250 VOLTS
250 VOLTS
27.3 VOLTS
=10
GRIG-NUBER 1 VOLTAGE IN VOLTS
OPERATION CHARACTERISTICS
= 4.3 vouTS (Rus) FH
aa]
Ko55611-T052-5,
4000 000
LOAD RESISTANCE IN OHWS
Et
DecemBeR 23,
42
10
°
1958
200
240
200
160
120
6BQ5
ET-T1535
Pag
CURRENT IN MILLIAMPERES
SCREEN
140
120
100
80
TW MI LLIAMBERES
60
40
eo 5
359
2) IN MILLIAMPERES
CURRENT
screen6BQ5
ET-TI535
Page 6
558
7 28 OPERATION CHARACTERISTICS Ds
Hf = bso vours a
6 24h 250 VOLTS 60 30
3B 2 so Bass
Bogie go 188
“ag of op we
14 tos
°
oe : 2 3 :
Ko55611-7052-6 WNPUT SIGNAL tm VOLTS (RMS) DECEMBER 17, 1958
ae OPERATION CHARACTERISTICS “od
ou nos
10
5 2 sg feceracs or sreten aaglaass £5
B53 feeibaraes a=
eos uliiedl oe
Pree ae ea meete|
e SHE HES To TURES PuSH-PULL 8
Eee tte f CLASS AB)
NSU E aia ieaTion arco vawue ter = -13 vours HH? 4
cae = 6500 onus
°
°° 10 20 30 0
PEAK INPUT SIGNAL, GRI0=10-CR10
ELECTRONIC COMPONENTS DIVISION
GENERAL @® ELECTRIC
Schenectady 5, N. Y.
kepsetietosze7 pecewsen 11, 1958