Your Blazer
Developed to the latest findings of automobile research, it offers
technical sophistication and exceptional comfort. Particular emphasis
was placed on using environmentally sound, recyclable materials,
throughout the design process. Your Blazer represents an ideal
synthesis of advanced technology, outstanding safety, environmental
compatibilty and economy in operation.
Your Blazer may use Premium, Premix or Unleaded fuel.
It now lies with you to drive your Blazer safety and to see it performs perfectly.
Make use of this owners manual:
CAUTION:
These mean there is something that could hurt you or
other people.
NOTICE:
These mean there is something that could damage
your vehicle.
ii
CAUTION: (Continued)
CAUTION: (Continued)
iii
NOTICE:
NOTICE: (Continued)
NOTICE: (Continued)
iv
NOTES
NOTES
vi
Section 1
Audio System
See the audio system supplement for information on
how to use your audio system and set the clock.
Antenna
NOTICE:
Added sound euipment like a mobile
telephone or two-way radio may interfere with
the operation of your vehicles engine, radio or
other systems, and even damage them. Check
with your dealer.
1-1
Instrument Panel
1.
2.
3.
4.
5.
Air Vents
Comfort Controls
Instrument Cluster
Glove Box
Ashtray
6.
7.
8.
9.
Cigarette Lighter/Power
Auxiliary Outlets
(Option)
Storage Compartment
Audio System
Rear Window Defogger
1-2
The instrument panel is designed to let you know at a glance how your vehicle is running.
1-3
100
60
oC
130
1-4
Odometer
Fuel Gage
Trip Odometer
The trip odometer can tell you how far your vehicle has
been driven since you last set the trip odometer to zero.
To set the trip odometer to zero, press the button near
the readout.
Speedometer
Tachometer
NOTICE:
Do not operate the engine with the tachometer in the
red area, or engine damage may occur.
1-5
Voltmeter
14
9
- +
19
250
500
kPa
1-6
Warning Lights
- +
1-7
1-8
CHECK
GAGES
1-9
Lamps
License Lamps
Sidemarker Lamps
Instrument Panel Lights
Interior Courtesy Lamps
Brightness Control
The INT LIGHTS switch controls the brightness of the
instrument panel lights. Rotate the switch all the way up
to turn on the interior lamps.
1-10
Press the side of the switch with the fog lamp symbol to
turn the fog lamps on. Press OFF to turn them off. A
light will glow in the switch shen to fog lamps are on.
Remember , fog lamps alone will not give off as much
light as your headlamps. Never use your fog lamps in
the darks without turning on your headlamps.
Fog lamps will go off whenever your high-beam
headlamps come on. When the high beams go off, the
fog lamps will come on again.
Dome Lamp
When the doors are opened, the dome lamp will come on.
Use your fog lamps for better vision in foggy or
misty conditions. Your parking lamps or low-beam
headlamps must be on for your fog lamps to work.
1-11
Hood Release
NOTICE:
The maximum load of any electrical equipment
should not exceed 20 amps.
Leaving electrical equipment on for extended
preiodes of time can drain your battery.
1-12
NOTICE:
Dont hold a cigarette lighter in with your hand
while it is heating. If you do, it wont be able to
back away from the heating element when its
ready. That can mae it overload, damaging the
lighter and the heating element.
NOTICE:
Dont put papers and other things that burn into
your ashtray. If you do, cigarettes or other smoking
materials could set them on fire, causing damage.
To remove the front ashtray, lift the release tabs as high
as possible, then remove the tray.
These vehicles have smaller ashtray inside the rear
doors. Press PUSH to turn the ashtray around for use.
1-13
Comfort Controls
Fan Control
The Switch with the fan symbol changes the fan speed.
To increase the fan speed, move the switch upward. To
decrease the fan speed, move the switch downward.
Temperature Knob
The upper knob regulates the temperature of the air
coming through the system. Turn the knob clockwise for
warmer air. Turn the knob counterclockwise for cooler air.
Mode Knob
The lower knob allows you to choose the direction of air
delivery.
1-14
1-15
Air Conditioning
Ventilation System
1-16
NOTICE:
Dont use a razor blade or something else sharp
on the inside the rear window. If you do, you
could cut or damage the warming grid.
1-17
Horn
Sound the horn by pressing the horn symbols on the
steering wheel.
Ignition Switch
Place the wheel where you like it and the release the
lever. It is recomended that you use the upper most
position only for entry and exit.
1-18
Multifunction Lever
Flash-To-Pass Feature
Pull the multifunction lever toward you to operate this
feature.
1-19
Windshield Wipers
Windshield Washer
Press and release the paddle to spray washer fluid on the
windshield. The washer will spray several times and
then stop. The wipers will clear the windows and then
either stop or return to yout preset speed.
1-20
To turn the rear wiper on, press ON. The wipper will
operate in five seconds intervals.
To spray washer fluid on the rear window, press and
hold ON.
WASH
ON
OFF
REAR WIPER
1-21
Mirrors
Outside Mirrors
CAUTION:
1-22
Sun Visors
To block out glare, you can swing down the top and
bottom visors. You can also swing the botton visor from
side to side. Your visors may have an extension that can
be pulled out for additional glare protection and a strap
for holding small items, such as maps.
1-23
Pull the passengers side sun visor down and lift the
mirror cover to turn on the lamps. You may also have
an illuminated mirror on the drivers side.
Power Windows
1-24
Lockout Switch
The lockout feature prevents passengers from
operating power windows. Press LOCK to activate
this feature. Press NORM and the windows return to
normal operation.
Doors
Door Locks
You can use the manual
door lock to lock and unlock
each door individually from
the inside.
Use your key to lock or unlock the front doors from the
outside.
For safety reason, only one side door can open with
key and if you want to open all door you must press
LOCK or UNLOCK to open and lock all door.
1-25
The rear doors are equipped with locks that help prevent
pasengers, especially children, from opening the rear
doors from the inside.
To use this feature, open a rear door and move the
switch to ENGAGED. Open the door from the outside
and move the switch away from ENGAGED to
disengage this feature.
1-26
CAUTION:
1-27
1-28
1-29
Storage
The front doors provide space fo storage.
There are also storage areas in the overhead console.
The glove box include cupholders.
You may have a console compartment which includes
cupholders, coinholders and a storage area for cassettes.
1-30
NOTES
1-31
NOTES
1-32
Section 2
Seat Controls
Manual Seat Lever
CAUTION:
Do not adjust the drivers seat when the vehicle
is moving. The seat could jerk and cause a loss
of control.
2-1
CAUTION:
Head Restraints
For your convenience, the front head restraints are
removable for maintenance purposes.
To recline the seatback, lift the lever and tilt the
seatback forward or backward, as desired. Release the
lever to lock the seatback in place.
2-2
Your vehicle has a folding rear seta which let you fold
the seatbacks down for more cargo space. The rear seat
release handles are in the upper center of the rear of
the seatbacks.
2-3
Safety Belts
CAUTION:
Lap-Shoulder Belt
The lap-shoulder belt should be worn properly, as
described. To fasten the belt:
1. Adjust the seat and sit up straight.
2. Pick up the latch belt.
3. Pull the belt across you. Do not let it get twisted.
2-4
5.
4.
2-5
The lap part of the belt should be worn low and snug on
the hips, just touching the thighs. In a crash, this applies
force to the strong pelvic bones. And youd be less
likely to slide under the lap belt. If you slid under it, the
belt would apply force at your abdomen. This could
cause serious or even fatal injuries. The shoulder belt
should go over the shoulder and across the chest.
These parts of the body are best able to take belt
restraining forces.
CAUTION:
2-6
NOTICE:
Your vehicle may be equipped with the rear shoulder belt
guides which provide comfort and support for small
adults and children. These guides work by pulling the
regular belt away from the neck and head.
2-7
Lap Belt
3.
2.
2-8
2-9
Child Restraints
Top Strap
CAUTION:
2-10
NOTES
2-11
NOTES
2-12
Section 3
NOTICE:
Your vehicle doesnt need an elaborate
break-in. But it will perform better in the long
run if you follow these guidelines:
Keep tour speed at 90 km/h or less for the
first 800 km.
NOTICE: (Continued)
NOTICE: (Continued)
3-1
Keys
This vehicle has one
double-sided key which is
used for the ignition and
all the locks.
The key has a bar code tag which is given to the first
owner at delivery. The bar code tells your dealer or a
qualified locksmith how to make extra keys. Keep this
tag in a safe place. If you lose your keys, youll be able
to have new ones made easily using this tag.
3-2
Ignition Switch
Use the key to turn the ignition switch to five different
positions.
NOTICE:
Dont operate accessories in the ACCESSORY
position for long periods of time. Prolonged
operation of accessories in the ACCESSORY
position could drain your battery and prevent you
from starting your vehicle.
LOCK (B): This position locks your ignition and
steering wheel. Its a theft-deterrent feature. You will
only be able to remove your key when the ignition is
turned to LOCK.
OFF (C): This position unlocks the steering wheel
and ignition. Use this position if your vehicle must be
pushed or towed, but never try to push-start the engine.
A warning tone will sound if you open the drivers door
when the igniton is off and the key is in the ignition.
3-3
NOTICE:
If your key seem stuck in LOCK and you can;t
turn it, be sure it is all the way in. If it is, then
turn the steering wheel left and right while you
turn the key hard. But turn the key only with
your hand. Using a tool to force it could break
the key or the ignition switch. If none of this
works, then your vehicle needs service.
3-4
Starting Instructions
The gear selector should be in NEUTRAL (N).
CAUTION:
NOTICE:
Holding your key in START for longer than
15 seconds at a time will cause your battery to
be drained much sooner. And the excessive heat
can damage your starter motor.
NOTICE:
Your engine is designed to work with the
electronics in your vehicle. If you add the electrical
parts or accesories, you could change the way
engine operates. Before adding electrical
equipment, check with your dealer. If you dont
your engine might not perform properly.
3-5
Manual Transmission
1
Vehicle Parking
Place your transmission in REVERSE (R) and firmly
apply the parking brake.
Control of A Vehicle
2
NOTICE:
Shift to REVERSED (R) only after your vehicle is
stopped. Shifting to REVERSE (R) while your
vehicle is moving could damage your transmission.
Steering
Power Steering
If you lose power steering assist because the engine
stops or the system is malfuntion ning, you can steer
but it will take much more effort.
3-6
Brakes
Brake Adjustment
Rear Brakes
Your rear brakes dont have the wear indicators. If you
ever hear a rear brake rubbing noise, have the rear brake
linings inspected. The rear brake drums should be
removed and inspected each time the tires are removed
for rotation or changing.
3-7
Parking Brake
3-8
Vehicle Loading
Maximum Front and Rear Axle Weights
The GVWR (Gross Vehicle Weight Rating) is the
maximum permissible loaded weight of the vehicle,
taking into account the capability of the engine,
transmission, frame, springs, brakes, axles and tires.
The weight of the cargo load must be properly
distributed over both the front and rear axles. The
Certification label shows the maximum weight that the
front axle can carry (fron GAWR) and the maximum
weight that the rear axle can carry (rear GAWR).
CAUTION:
The components of your vehicle are designed to
provide satisfactory service if the vehicle is not
loaded in excess of front and rear Gross Axle
Weight Ratings (GAWRs). Overloading can
result in loss of the vehicle control and personal
injury. It can also shorten the service life of
your vehicle.
3-9
Certification Label
Suspension
3-10
Section 4
Leaded Fuel
You should use 88RON leaded gasoline. The use of
other gasolines may cause engine knock. Continued
use can cause engine damage.
If you detect a heavy engine knock even when using
88RON leaded gasoline, have the engine checked.
Short periods of engine knock during hill climbing and
acceleration are acceptable.
CAUTION:
Gasoline vapor is highly flammable. Keep
sparks, flames and smoking materials away
from gasoline.
4-1
CAUTION:
If you open the cap rapidly while pressure inside
the tank is high, gasoline may spray out from the
tank. Before you fully open the cap, turn it
slightly to release the pressure from inside the
tank to avoid possible injury.
NOTICE:
If you have to get a new cap, be sure to get the
right one. Otherwise the cap might not have
the proper venting. This could lead to serious
fuel system and other damage. Your dealer
knows the correct cap for your vehicle.
4-2
Hood Release
To open the hood, first pull
the handle inside the
vehicle, located below the
lower right side of the
instrument panel.
4-3
When you open the hood of the dual cam engine, youll see:
1.
2.
3.
4.
5.
6.
7.
8.
9.
4-4
When you open the hood of the single cam engine, youll see:
1.
2.
3.
4.
5.
6.
7.
8.
9.
4-5
Engine Oil
NOTICE:
Dont add too much oil. If your engine has so much
oil that the oil level gets above MAX, your engine
could be damaged.
4-6
4-7
Engine Coolant
The cooling system in your vehicle is filled with the
new long life engine coolant.
If you have a problem with engine overheating, see
Engine Overheating in the Index.
NOTICE:
When adding coolant, it is important that you use
long life coolant. If silicated coolant is added to
the system, premature engine, heater core or
radiator corrosion may result and the coolant will
require change sooner.
4-8
CAUTION:
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mix will. With plain water or the wrong
mix, your engine could get too hot but you
wouldnt get the overheat warning. Your engine
could catch fire and you or others could be
burned. Use a 50/50 mix of clean water and
extended life coolant.
NOTICE:
If you use an improper coolant mix, your engine
could overheat and be badly damaged. Too much
water in the mix can freeze and crack the engine,
radiator, heater core and other parts.
CAUTION:
You can be burned if you spill collant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Dont spill coolant on a hot engine.
4-9
To add fluid:
1. Remove the filler plug.
2. Add fluid at the filler plug hole. Add only enough
fluid to bring the fluid level up to the bottom of
the filler plug hole.
3. Install the filter plug. Be sure the plug is fully
seated.
4-10
There are only two reasons why the brake fluid level in
the reservoir might go down. The first is that the brake
fluid goes down to an acceptable level during normal
brake lining wear. When new linings are put in, the
fluid level goes back up. The other reason is that fluid
is leaking out of the brake system. If it is, you should
have your brake system fixed, since a leak means that
sooner or later your brakes wont work well, or wont
work at all.
4-11
You can check the brake fluid without yaking off the cap.
Just look at the windows on the brake fluid reservoir.
The fluid levels should be above MIN. If they arent,
have your brake system checked to see if there is a leak.
CAUTION:
If you have too much brake fluid, it can spill on the
engine. The fluid will burn if the engine is hot
enough. You or others could be burned, and your
vehicle could be damaged. Add brake fluid only
when work is done on the brake hydraulic system.
4-12
Battery
You should check the electrolyte level regularly.
Remove the vent plug. If the level is low, add
drinking-quality water that is colorless and odorless.
Add water until the level reaches the split vent located
in the bottom of the vent well. Do not overfill.
Overfilling will result in poor performance, short life
and excessive corrosion.
Check the outside of the battery periodically for
damage. Remove acid film and dirt with diluted
ammonia and flush with water.
4-13
Vehicle Storage
If youre not going to drive your vehicle for 25 days or
more, take off the black, negative (-) cable from the
battery. This will help keep your battery from running
down.
Contact your dealer to learn how to prepare your
vehicle for longer storage periods.
2.
3.
4.
5.
6.
7.
4-14
Tires
Tire Inspection and Rotation
To make your tires last longer, have them inspected and
rotated at the recommended mileages. When rotating
your tires, always use one of the correct patterns shown
here.
4-15
Tire replacement
4-16
CAUTION:
Never dirve faster than the speed for which your tires
are rated, regardless of the legal speed limit. If you
anticipate driving your vehicle at high speeds
frequently and/or for prolonged periods of time, check
with your dealer for the proper type of tires to use for
your specific driving and weather conditions.
NOTICE:
Vehicles left standing for an extended period of time
may be prone to exhibit flat spotting on the tires.
4-17
PWR
WDO
HORN
DM
R/DEFR
INJ
ENG
FAN
12
BRAKE
INJ
18
24
EST IGN
GAUGES
11
WIPER
ECM
IGN
17
23
RADIO
T/L
R. WASH
10
16
22
TURN
B/U
F/PMP
RLY+2
15
21
ECM
BATT
FOG
ILLUM
STOP
HAZ
14
20
ELECT
SHIFT
PWR
AUX
RDO
BATT
13
19
4WD
PWR
ACCY
HTR
A/C
4-18
Bulb Replacement
2.
Before you replace any bulbs, be sure that all the lamps
are off and the engine isnt running. See Replacement
Bulbs in the Index for the proper type of bulb to use.
Headlamps
Sealed Beam Lamps
1.
4-19
Composite Headlamps
1.
2.
4.
6.
7.
8.
4-20
1.
2.
3.
4.
5.
4-21
Taillamps
1.
4.
5.
6.
7.
8.
9.
3.
4-22
Replacement Bulbs
Lamps
Halogen Headlamps, Sealed Beam
Halogen Headlamps, Composite Low Beam
Halogen Headlamps, Composite High Beam
Tail and Stoplamps
Turn Signal Lamps
Quantity
2
2
2
4
2
Number
2EI
9006 HB4
9005 HB3
3057
3157 NA
S
L4
2.2L
1-4-3-2
127 hp at 5200 rpm
82 C
H
L4
2.2L
1-4-3-2
138 hp at 5600 rpm
82 C
4-23
Capacities (Approximate)
Cooling System* ..................................... 8.5 L
Crankcase* ............................................. 4.1 L
Fuel tank ................................................. 68 L
A/C Refrigerant (R-134a) .................. 0.795 kg
* After refill , the level must be checked.
Vehicle Dimensions
Wheelbase ........................................ 271.8 cm
Length (Rear bumper not included) ... 460.2 cm
Height .............................................. 167.4 cm
Width ............................................... 169.0 cm
Front Tread ....................................... 139.6 cm
Rear Tread ........................................ 137.5 cm
4-24
Section 5
Jump Starting
If your battery has run down, you may use another
vehicle with a 12-volt battery and some jumper cables
to start your vehicle.
CAUTION:
NOTICE:
Ignoring these steps could result in costly damage
to your vehice.
5-1
1.
3.
4.
NOTICE:
If the other system isnt a 12-volt system with a
negative ground, both vehicles can be damaged.
2.
CAUTION:
5-2
5.
6.
7.
8.
Dont let the other end touch anything until the next
step. The other end of the negative (-) cable
doesnt go to the dead battery. It goes to a heavy
unpainted metal part on the engine of the vehicle
with the dead battery.
9.
10. Now start the vehicle with the good battery and
run the engine for a while.
5-3
CAUTION:
-B +
1
4
A
A.
B.
C.
- C+
5-4
Towing
NOTICE:
Dont have your vehicle towed on the rear wheels,
unless you must. If you cannot avoid towing the
vehicle on the drive wheels, do not drive faster
than 50 km/h or farther than 80 km.
To help avoid damage to the vehicle once it is
secured to the tow truck:
1. Turn the ignition key to the OFF position
2. Have the steering whell calmped in a
straight-ahead position. Do not use the
vehicles steering column lock for this.
3. Shif the gear level to NEUTRAL (N).
4. Release the parking brake.
Towing Devices
Front and rear towing devices are attached on the left
side. Towing devices are rated at one half of the Gross
Vehicle Weight.
Make sure you use a 10 cm x 10 cm wood plank to
avoid damaging the frame of the license plate.
5-5
Engine Overheating
If you see or hear steam
coming from the engine,
stop and turn off the engine.
Do not open the hood until
the engine has cooled down.
CAUTION:
5-6
NOTICE:
If your engine catches fire because you keep driving
with no coolant, your vehicle can be badly
damaged.
If the coolant temperature gage shows an overheat
condition, but you see or hear no steam, try this for a
minute or so:
1. Turn off your air conditioner and turn on your heater
to full hot at the highest fan speed. Open the window
as necessary.
2. If youre in a traffic jam, shift to NEUTRAL (N);
otherwise, shift to the highest gear while driving.
5-7
CAUTION:
5-8
CAUTION:
5-9
3.
1.
2.
To remove the
underbody-mounted
spare, insert the
chisel end of the
wheel wrench, on an
angle, into the gole
in the rear bumper.
Be sure the chisel
end of the wheel
wrench connects into
the hoist shaft.
NOTICE:
Never remove or restow a tire from/to a stowage
position under the vehicle while the vehicle is
supported by a jack. Always tighten the tire fully
against the underside of the vehicle when
restowing.
5-10
4.
5.
6.
7.
Pry the hub cap off with the flat end of the wheel
wrench.
8.
9.
CAUTION:
5-11
NOTICE:
Raising your vehicle with the jack improperly
positioned will damage the vehicle or may allow
the vehicle to fall off the jack. Be sure to fit the
jack lift head into the proper location before
raising tour vehicle.
11. Remove all the wheel nuts and take off the flat
tire.
5-12
CAUTION: (Continued)
wheel, remove any rust or dirt from the places
where the wheel attaches to the vehicle. In an
emergency, you can use a cloth or a paper towel
to do this; but be sure to use a scrapper or wire
brush later, if you need to, to get all the rust or
dirt off.
CAUTION:
CAUTION:
CAUTION: (Continued)
5-13
5-14
CAUTION:
5-15
CAUTION:
A.
B.
C.
D.
E.
F.
G.
Retainer
Rubber Band (Some Models)
Jack Storage Cover
Whell Blocks
Wheel Wrench
Jack
Jacking Instruction
5-16
Section 6
Index
Capacities
Air Cleaner
Air Conditioning
Refrigerants
Antenna
Ashtrays
Audio Systems
Battery
Charge Light
Jump Starting
Brakes
Adjustment
Anti-Lock
Fluid
Master Cylinder
Pedal Travel
Rear
System Warning Light
Wear Indicators
Bulb Replacement
Dead Battery
Defogger
Dimensions, Vehicle
Dome Lamps
6-1
Filter, Air
Instrument Panel
Cluster
Fuse Block
Interior Lamps
Head Restraints
Headlamps
High-Beams
On Reminder
Heating
Hood Release
Horn
Ignition Switch
Jacking Equipment
Gages
Keys
Jump Starting
6-2
Lamps
Parking
Lighter
Lights, Warning
Loading Your Vehicle
Lockout Siwtch, Windows
Locks
Brake
Vehicle
Power Steering Fluid
Pregnancy, Use of Safety Belts
Problems on the Road
Mirrors
Illuminated Visor vanity
Inside Day/Night Rearview
Visor Vanity
Multifunction Lever
Rearview Mirror
Reclining Front Seatbacks
Replacement Bulbs
Rotation, Tires
Safety Belts
Center Passenger Position
Lap Belt
Lap-Shoulder
Rear Shoulder Belt Height Adjuster
Reminder Light
Replacing
Use During Pregnancy
6-3
Safety Precautions
Seats and Safety Belts
Service and Maintenance
Shifting
Specifications
Speedometer
Starting Your Engine
Steam
Steering
Steering Wheel
Storage Compartments
Storage, Vehicle
Suspension
Tachometer
Temperature and Compass Display
Tilt Steering Wheel
Tires
Changing a Flat
Inspection and rotation
Wear Indicators
Top Strap
Vehicle
Control
Dimensions
Loading
Storage
Ventilation System
Visors, Sun
Voltmeter
Warning Lights
Wheel Nut Torque
Windows
Windshield Washer
Windshield Wipers
6-4
3-10
12
15
18
22.5
24
30
30
37.5
36
45
42
52.5
48
60
54
67.5
60
75
66
82.5
72
90
78
97.5
84
105
P
P
G
P
P
P
P
P
P
P
G
G
P
P
P
P
P
G
G
P
P
P
P
P
P
P
G
G
P
P
P
P
P
P
G
P
P
P
P
P
P
G
G
G
P
P
P
P
P
P
G
P
G
G
P
P
G
P
P
G
G
P
P
G
P
P
G
G
P
P
G
P
P
G
G
P
P
G
P
P
G
G
P
P
G
P
P
G
G
P
P
G
P
P
G
G
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P/B
P
P
P
P
P/B
P
P
P
P
P/B
P
P
G
G
P
P
P/B
P
P
P
P
P/B
P
P
P
P
P/B
P
G
G
G
P
P
P/B
G
G
96
120
102
127.5
108
135
114
142.5
120
150
P
P
G
G
P
P
P
P
P
G
G
P
P
P
P
P
P
P
G
G
G
G
P
P
G
P
P
G
G
P
P
G
P
P
G
G
P
P
P
P
P
P
P
P
P
P
P
P/B
P
P
P
P
P/B
P
P
P
P
P/B
P
G
G
G
G