2. Design a Schmitt trigger for V UT= 100 mV and VLT=-100mV. Use 741 OP-AMP and 15 V
power Supply. Draw circuit diagram and transfer characteristics.
3. In the Op-Amp circuit shown, assume that the diode current follows the equation I=I s
exp(v/vt). For Vi=2v, vo=vo1 and for vi=4v, v0=vo2 than obtain the relationship between vo1 and vo2.
4 The circuit shown in fig. below is at steady state before the switch opens at t = 0. Calculate
the vc(t) for t >0.
5. In the circuit of fig. below3.5.11 the voltage vi1= is (1+2 sin2t) mV and vi2=-10 mV.
Calculate the output voltage
6. Find the value of R in the circuit of Fig. below for generating sinusoidal oscillations. Find the
frequency of oscillations
7. In Figure below assume the OP-AMPs to be ideal. Calculate the output of the circuit
8. In the op-amp circuit given in Figure below Calculate the load current IL
9. Calculate the transfer characteristic for the precision rectifier circuit shown below is (assume
ideal OP-AMP and practical diodes)
10. Obtain the transfer funtion of the circuit given beleow and sketch the frequency response.
11. Obtain the value of VUT and VLT of the non-inverting Schmitt trigger circuit shown in the
figure below. Also Sketch the transfer characteristics of the circuit.