Ver 1.0
Circular pile
Pile geometry
Soil properties
0.2
Layer i
Depth to the
layer Hi (m)
Young's modulus
of the soil Esi (MPa)
19
12
50
Young's modulus of
the pile Ep (GPa)
27
19
117
21
117
40
138
Soil layers
Number of soil layers
within the pile
Number of soil layers
below the pile base
5
2
7
8
Load
Load at the
pile head Qt (kN)
9
542
10
Output
Poisson's ratio
of the soil si
Head settlement
wt (mm)
Base settlement
wb (mm)
Base load
Qb (kN)
0.3
0.3
0.3
0.3
Run
3.61
0.13
17
0.0227335
5 iterations
Qt (kN) = 542
Qb (kN) = 17
Original configuration
Deformed configuration
200
times
100
200
300
400
500
600
0
0.5
0.5
soil displacement (mm)
0
0
1
1.5
2
2.5
3
3.5
4
10 12 14 16 18 20
1
1.5
2
2.5
3
3.5
4
Axial load (kN)
0.5
1.5
2.5
3.5
6
Depth (m)
Depth (m)
8
10
12
200
300
8
10
12
14
14
16
16
18
18
20
100
20
Pile displacement (mm)
400
500
600
10 12 14 16 18 20
00
300
400
500
600
Layer
1
2
3
4
Hi (m)
ki (Pa)
ti (N)
12
19
21
40
2.25E+07
5.27E+07
5.27E+07
6.22E+07
6.34E+07
1.48E+08
1.48E+08
1.75E+08
i (m-1)
0.152041
0.214624
0.419880
0.419880
ai (N/m)
Bi (m)
Ci (m)
1.48E+08
2.46E+08
1.26E+08
1.48E+08
-2.198E-05
5.156E-07
-6.748E-10
0.000E+00
3.634E-03
5.824E-03
3.884E-01
3.565E-01
msi (Nm)
nsi (N/m)
648.9
18.0
0.6
0.1
32.8
1.4
0.2
0.1
r
0.02273
0.02273
0.02273
0.02273
If ALPAXLVer 1.0 does not work properly, please check whether the Analysis TookPak add-in is intalled.
The installation procedures of the Analysis ToolPak are as follows:
1. On the Tools menu, click Add-Ins.
2. In the Add-Ins available list, select the Analysis ToolPak box, and then click OK.
k add-in is intalled.