PM service Tips:
Normally a good cleaning of the machine would vacuum any foreign material out
above and below the rubber disk.
The sensors can be cleaned with a "Q" tip and alcohol (2000 Model). The Metal
sort disk can be scraped with a metal brush freeing it of any build up in the
grooves.
"RECON" Message- Power down and back up to see if fault clears-Clean and
check sensors
Hot Keys:
Hard Reset to Default: Turn off then back on the "power button" while
pressing and holding down the "RED" button on the keyboard.
Program Mode: Turn off then back on the "power button" while pressing and
holding down the "Start/Batch" button on the keyboard.
Program Navigation:
"<>" button will move cursor to the right or left through menu
"Continue" button will select desired menu selection and change setting from
"box" to "bag" if continually pressed
"TO set any changes" to memory power down by power switch will set changes
Printer:
Citizens Printer