Anda di halaman 1dari 1

For the power supply a universal AC/DC (3 - 12V) adaptor

16 - 30 V (DC) +13V
can be used. The switch must be in position 12V. It is 12 - 20 V (AC) IC1 VCC
IC2 VPP
recommended to change the capacitor inside the adaptor VIN G1
with capacitor for a minimum 25 V. Check the output B80C800 78L05 78L08
1 2 1 1 3 1 3
voltage (unloaded), it must be at least 16V for PIC16C6x AC + Vin Vout Vin Vout

GND

GND
and PIC16C7x and minimum 14V for PIC16C84. 0
4 3
AC -

2
VPP C1
C2 100nF
220uF/40V
T3 100nF
BC557 C3 14
LPT GND (18-25)
74LS05
7
R9
4k7

74LS05
Vpp40 On/Off
1 2 R10
LPT D4 (6)
4k7
D3 Non inverting (74LS07) or inverting
Red (74LS05, 74LS06)
VPP VPP open collector buffers can be used.
T1
BC557 TEXTOOL 40 ZIF
1 40
MCLR RB7
2 39
RA0 RB6
D1 D2 VCC 3 38
RA1 RB5
R2 Red Green 4 37
RA2 RB4
4k7 5 36
RA3 RB3
6 35
RA4 RB2 28 PIN PICs must be put in
7 34
R8 * R6 R7 RA5 RB1 40 PIN TEXTOOL with PIN 1 on PIN 1
8 33
10k 10k 10k RE0 RB0 (upper part of textool)
9 32
R9 RE1 VDD
74LS05 R1 10 31
680E RE2 VSS
Vpp On/Off 1k 74LS05 11 30
R4 VDD RD7 18 (20) PIN PICs must be put in
9 8 Data Out 12 29
LPT D3 (5) VSS RD6 40 PIN TEXTOOL with PIN 9 (10) on PIN 20
4k7 3 4 13 28
LPT D0 (2) OSC1 RD5 (lower part of textool)
14 27
OSC2 RD4
15 26
RC0 RC7
VCC 16 25
RC1 RC6 8 PIN PICs must be put in
T2 17 24
74LS05 RC2 RC5 40 PIN TEXTOOL with PIN 1 on PIN 3
BC557 Data In 18 23
RC3 RC4
10 11 19 22
LPT ACK (10) RD0 RD3
20 21
RD1 RD2
R3
4k7 74LS05
Clock
5 6
LPT D1 (3)

74LS05
Vdd On/Off
13 12 R5
LPT D2 (4)
4k7
C4 *
330pF
T
e P16PRO programmer for PIC16Cxx microcontrollers by Bojan Dobaj
x
t

Anda mungkin juga menyukai