0 penilaian0% menganggap dokumen ini bermanfaat (0 suara)
1K tayangan185 halaman
MIL-STD-1689 has been redesignated as a Manufacturing Process Standard. The cover page has been changed for Administrative reasons. This Military Standard is approved for use by the Naval Sea Systems command, Department of the navy.
MIL-STD-1689 has been redesignated as a Manufacturing Process Standard. The cover page has been changed for Administrative reasons. This Military Standard is approved for use by the Naval Sea Systems command, Department of the navy.
Hak Cipta:
Attribution Non-Commercial (BY-NC)
Format Tersedia
Unduh sebagai PDF, TXT atau baca online dari Scribd
MIL-STD-1689 has been redesignated as a Manufacturing Process Standard. The cover page has been changed for Administrative reasons. This Military Standard is approved for use by the Naval Sea Systems command, Department of the navy.
Hak Cipta:
Attribution Non-Commercial (BY-NC)
Format Tersedia
Unduh sebagai PDF, TXT atau baca online dari Scribd
NOTE: MIL-STD-1689 has been redesignated as a Manufacturing Process Standard
‘The cover page has been changed for Administrative reasons. There are no
other changes to this Document
INCH-POUND,
MIL-STD-1689A (SH)
V4
SUPERSEDING
MIL-STD-1689 (SH)
27 DECEMBER 1983
(SEE 175)
DEPARTMENT OF DEFENSE
MANUFACTURING PROCESS STANDARD
FABRICATION, WELDING, AND INSPECTION OF
SHIPS STRUCTURE
AMSC N/A, AREA THOM
DISTRIBUTION STATEMENT A. Approved for public release; distribution is
unlimitedMIL-STD-1689A(SH)
FORWARD
1. This Military Standard is approved for use by the Naval Sea Systems
Command, Department of the Navy, and is available for use by all Departments
and Agencies of the Department of Defense.
2. Beneficial comments (recommendations, additions, deletions) and any
pertinent data which may be of use in improving this document should be
adéressed to: Commander, Naval Sea Systems Command, SEA 5523, Department of
the Navy, Washington, DC 20362-5101 by using the self-addressed
Standardization Document Improvement Proposal (DD Form 1426) appearing at the
end of this document or by letter.
itDUR oN
10
MIL-STD-1689A(SH)
CONTENTS
SCOPE.
Scope ....
General ..
References .
Requirements subject to Naval Sea Systems
Command (NAVSEA) approval ......... 0000+
REFERENCED DOCUMENTS ...
Government documents .
Specifications and standards .
Other Government publications
Non-Government publications ..
Order of precedence
DEFINITIONS
General .....
Acceptable ...
Activity
Approval (approved)
Arc strike
Backgouge . boos
Ballistic plating ........
Bulkheads .
Closure bulkhead (submarines)
Containment bulkhead
Holding bulkhead (submarines)
Structural bulkhead ..........
Enclosure bulkhead .......
Interior bulkhead
Buildup
Butt
circularity .
Coamings .....
Submarines ..
Surface ships
Control surfaces
Corner crack .
Decks, main strength (surface ships)
Erection .....
Fabrication ..
Foundation
Fragmentation plating ..
High-hardenable materials ......
Higher strength steel (HSS) ....
High strength low alloy steel .
iii
» vee §