0 penilaian0% menganggap dokumen ini bermanfaat (0 suara)
99 tayangan5 halaman
The Radial Heat Conduction Module (h111b) contains an insulated disc of brass (3.2mm thick x 110mm diameter)with a brass core (14mm diameter) and an electric heater at the center. Six type K thermocouples are positioned at inc. Radii from the heated center to record the temp. Distribution across the disc. Each thermocouple is fitted with a miniature plug for direct connection to the front panel of the heat transfer service unit.
The Radial Heat Conduction Module (h111b) contains an insulated disc of brass (3.2mm thick x 110mm diameter)with a brass core (14mm diameter) and an electric heater at the center. Six type K thermocouples are positioned at inc. Radii from the heated center to record the temp. Distribution across the disc. Each thermocouple is fitted with a miniature plug for direct connection to the front panel of the heat transfer service unit.
Hak Cipta:
Attribution Non-Commercial (BY-NC)
Format Tersedia
Unduh sebagai DOC, PDF, TXT atau baca online dari Scribd
The Radial Heat Conduction Module (h111b) contains an insulated disc of brass (3.2mm thick x 110mm diameter)with a brass core (14mm diameter) and an electric heater at the center. Six type K thermocouples are positioned at inc. Radii from the heated center to record the temp. Distribution across the disc. Each thermocouple is fitted with a miniature plug for direct connection to the front panel of the heat transfer service unit.
Hak Cipta:
Attribution Non-Commercial (BY-NC)
Format Tersedia
Unduh sebagai DOC, PDF, TXT atau baca online dari Scribd
transfer ,will obtained using an experimental : setup consisting of many components P.A.Hilton heat conduction unit(H111B), - 1 which is used in the study of radial heat . conduction in the solids Universal "Heat transfer service unit - 2 . "((H111 . "(computerized " Data Logger (HC111A - 3
The Radial Heat Conduction Module (H111B)
contain an insulated disc of brass (3.2mm
thick x 110mm diameter)with a brass core
(14mm diameter)and an electric heater at
the center and the disk is also cooled by
water around its circumference from local
tap . 4 - six type K thermocouples are positioned
at inc. radii from the heated center to record
the temp. distribution across the disc. And
are located in drilled holes so that in each
case the measured point is in the center of
the disc thickness.
Each thermocouple is fitted with a miniature
plug for direct connection to the front panel
of the heat transfer service unit
And an edge connector for use with the
HC111A Data Logger .
5 – Voltage and Current outputs.
*the position of the thermocouples on the brass disc :-