: : :
STRUCTURAL ANALYSIS BAA2123 ENGR. MOHD FAIZAL MD JAAFAR ENGR. KHALIMI JOHAN ABD HAMID ENGR. ROKIAH OTHMAN 15 APRIL 2011 SESSION 2010/2011 SEMESTER II BAA / BAE
: : :
INSTRUCTIONS TO CANDIDATE: 1. 2. 3. 4. This assignment consists of FOUR (4) questions. Answer ALL questions. This is a group assignment of 4 MEMBERS (MAXIMUM) per group. All answers to a new question should start on new page. All the calculations must be shown and assumptions must be clearly stated.
ASSIGNMENT 2 QUESTION 1
A pin- jointed steel truss shown in Figure Q1 carries a 10 kN/m UDL on the top chord. By using the stiffness matrix method determine:-
a) the structure stiffness matrix, K b) the vertical and horizontal displacement at joint D. c) the force of each members
10 kN/m B
2 1 6 5 7
D C
3 4
3m
3m Figure Q1
ASSIGNMENT 2 QUESTION 2
Figure Q2 shows a pin- jointed truss structure which is loaded with 100 kN at joint A. Given E= 200 kN/ mm2 and the cross- sectional areas of AB and AD is 500 mm2, while AC is 400 mm2. By using the stiffness matrix method determine:-
a) the structure stiffness matrix, K b) the vertical and horizontal displacement at joint A. c) the force of each members
2 1 3
4m
100 kN 3m 3m Figure Q2
ASSIGNMENT 2 QUESTION 3
Figure Q3 shows a three spans portal frame structure which is fix supported at joints A and D. Given E= 200 kN/ mm2, I= 250 x 106 mm4 and A= 5000 mm2. By using the stiffness matrix method determine:-
a) the structure stiffness matrix, K b) the ends loadings of each members c) the deflections at joint B.
10 kN
4m
D 4m
Figure Q3
ASSIGNMENT 2 QUESTION 4
A pin- supported portal frame structure as shown in Figure Q4 is been loaded with a perpendicular 10 kN point load at the diagonal member. Given E= 200 kN/ mm2, I= 250 x 106 mm4 and A= 5000 mm2. By using the stiffness matrix method determine:-
a) the structure stiffness matrix, K b) the ends loadings of each members c) the deflections at joint B.
10 kN C 3m
2
4m
2m
2m
Figure Q4
END OF QUESTIONS