0 penilaian0% menganggap dokumen ini bermanfaat (0 suara)
53 tayangan5 halaman
Radiographs of welds exhibiting indications of incomplete fusion or incomplete penetration are Not Permitted. Gas pockets, circular voids, and well dispersed tungsten inclusions are to be treated as porosity. The maximum size of a single isolated pore may be 0.25t or 4. Mm which ever is less, where t is thickness of the material in mm. The total area of porosity should not exceed 2.3t mnr' in any 150 mm length
Radiographs of welds exhibiting indications of incomplete fusion or incomplete penetration are Not Permitted. Gas pockets, circular voids, and well dispersed tungsten inclusions are to be treated as porosity. The maximum size of a single isolated pore may be 0.25t or 4. Mm which ever is less, where t is thickness of the material in mm. The total area of porosity should not exceed 2.3t mnr' in any 150 mm length
Hak Cipta:
Attribution Non-Commercial (BY-NC)
Format Tersedia
Unduh sebagai PDF, TXT atau baca online dari Scribd
Radiographs of welds exhibiting indications of incomplete fusion or incomplete penetration are Not Permitted. Gas pockets, circular voids, and well dispersed tungsten inclusions are to be treated as porosity. The maximum size of a single isolated pore may be 0.25t or 4. Mm which ever is less, where t is thickness of the material in mm. The total area of porosity should not exceed 2.3t mnr' in any 150 mm length
Hak Cipta:
Attribution Non-Commercial (BY-NC)
Format Tersedia
Unduh sebagai PDF, TXT atau baca online dari Scribd
SCWI_bok
BODY OF KNOWLEDGE
Senior Certified Welding Inspector
All examinations for the AWS Senior Certified Welding Inspector are in open-book format. Candidates may bring to the
examination site any reference materials that they feel will assist them in taking the examinations.
The SCWI examinations will consist of two open book examinations, each lasting two hours. All applicants shall
successfully meet the SCWI requirements as contained in 6.2 of AWS B5.1, Specification for the Qualification of
Welding Inspectors. Candidates must pass each exam part with a minimum of 72%.
Approximate subject weights for the two examination parts are as follows: