There are some errors concerning the USB dongle when the following
image appears:
1. The USB dongle had been inserted before installing the driver.
2. The driver of the USB dongle was not successfully installed.
Render
It means that the USB dongle you’re using doesn’t match the program.
Tips & Tricks 05
Installation
That means you didn’t input the authorization code or the code is wrong.
Please input the right code.
Step 4: Cancel the tick of “Use User Account Control (UAC) to help
protect your computer”. Then click OK to confirm.
Authorization code
YFCAD software would only work, when the USB dongle is plugged.
During the installation process, the user will have to input the
authorization code that match the serial number of the USB dongle.
The authorization code is formed by 23 digits number.
InteriCAD 6000 has five sets of authorization codes while InteriCAD
T3 has four sets of authoriazation codes.
Click “Add” button to input the number. After inputting all the set of
codes, you can finally start using InteriCAD.
In Windows XP, you have to open the start menu to find the program
input the authorization codes after the installation
However in Vista, you have to turn the UAC off before double clicking
on the program from the start menu to run it.
Tips & Tricks 12
Installation
Block
Create a new drawing as a block from the original AutoCAD
drawing, and then insert it to InteriCAD file.
A: Enter “wblock” and press ENTER, and then enter a file name
and path for the new drawing, or click the [...] button to display
a standard file selection dialog box.
B: click OK button. Then input block name and press ENTER.
C: Specify insert point, and then select object to export. Press
ENTER or right click to finish the command.
D: Open InteriCAD drawing, and then select “Draw > Insert” from
menu bar to insert the block file into current drawing.
Insert
When the user uses “insert” command, the objects will become a
single object. That’s why user has to tick the “explode” command
to break compound object, such as an entire room or several
objects, into component objects.
Tips & Tricks 19
Modeling
A: Select “Draw > Insert” from menu bar, and then select the
preferred drawing to insert.
B: To break this drawing, select “Edit > Explode” from menu bar.
Then select object that you inserted just now. Press ENTER or
right click to finish the command.
Right click on the desktop. Then select Properties from the shortcut
menu. Switch to Setting label and change the colors quality content
to Highest (32bit) from the pull-down menu. Click OK button to
apply the change.
For Windows Vista,
right click on the
desktop then select
Personalize from the
shortcut menu. Then
select Display Setting
and change the color
content to Highest
(32bit) from the
pull-down menu.
Similarly, to get a better light effect, user could merge the models near
light source into VR using smaller mesh size. This way, customer can
get better light effect, and the data size won’t be too large.
What to do if there are dark areas or light leak along the edge
of some objects after performing radiosity?
Step 2: Select target objects (hold SHIFT key to select multiple objects).