The contact surface at B is smooth, whereas the coefficient of static friction between the rod and the wall at A is s = 0.2.
A
3m
B 4m
2. The 45-kg disk rests on the surface for which the coefficient of static friction is s = 0.2. Determine the largest couple moment M that can be applied to the bar without causing moment.
300 mm
400 mm
B 125 mm A
3. Each of the cylinders has a mass of 50 kg. If the coefficients of static friction at the points of contact are A = 0.5, B = 0.5, C = 0.5, and D = 0.6, determine the smallest couple moment M needed to rotate cylinder E.
M A B D C
4. Determine the moment of inertia of the shaded area about x axis. 300 mm
300 mm
1m
x
1m
5. Determine the moment of inertia of the area shown in figure below about its x-axis. (diameter = 50 mm)
50 mm 50 mm 60 mm 50 mm 80 mm
x
50 mm
3m
3m
4m
z7. Determine the moment of inertia of the cross-sectional area of the I-section with respect to the x and y-axis. y
40 mm
120 mm
40 mm 30 mm 100 mm
of the composite area, then determine the moment of inertia of this area y
240 mm
50 mm 80 mm C 250 mm
50 mm 45 mm 110 mm 45 mm
9. Determine the product of inertia for the beams cross-sectional area with respect to the x and y axes that have their origin located at the centroid C. y
10 mm 50 mm
10 mm
x
10 mm 50 mm 50 mm 50 mm
10. Determine the product of inertia of the beams cross-sectional area with respect to the x and y axes. y
10 mm
300 mm
10 mm 10 mm