P/N: 01PL0592
13 14 15 16
A B
A B C Latch A __ A
A B
C D
24V 0V 24V/ 0V
2 6 2 6
DC DC
Ue U0
N1 N2
0V 24 V
B __ B
C
N2 N1
L G
_ B/B
N1/ N2
3 7 3 7
C __ C Sensor supply 5V 0V
Ue U0 R S
Gate Latch
_ C/C
DC DC
4 8 4 8
Latch/ Gate
Gate/ Ref
Gate/Ref Latch
Ue/U0
750-637
This module is an interface for any incremental encoder with a RS 422 connection. A counter with quadrature decoder as well as a latch for the zero impulse can be read or enabled by the control. The control can set the counter or transmit the counter value to the Latch. As an alternative this can also be done using input C or Latch. The frequency data is automatically acquired and can also be transmitted to the control.
A counter lock-out is possible using input G. Input Ref can be used to activate the initial point C function. The outputs N1 and N2 indicate whether the counter value is within a defined range of values. The range can be adjusted. The module must be powered using an external 24 V DC power supply. It is then possible to supply the encoder with 24 V DC, or alternatively with 5 V DC derived internally from the terminations (Ve/V0). The shield (screen) is directly connected to the carrier rail.
Description
Incremental Encoder Interface Inkremental Encoder Interface 24 V/32 Bit differential Inkremental Encoder Interface 24 V/32 Bit single ended Inkremental Encoder Interface 24 V/32 Bit single ended/cam outputs
Pack. unit 2 1 1 1
1)
Technical Data
Transmitter connection Current consumption (internal) Counter Max. operating frequency (kHz) Quadrature decoder Zero impulse latch Commands Voltage supply Current consumption typ. Operating voltage of sensor Sensor max. output current Internal bit width Digital outputs (N1, N2) Output voltage Output current max Digital inputs (Latch, Gate, Ref) Signal voltage (0) Signal voltage (1) Input current typ. Wire connection Cross sections Stripped length Width Weight EMC 1-Immunity to interference EMC 1-Emission of interference A, A, B, B, C, C 110 mA 32 bits binary 250 kHz 4-fold report 32 bits read, set, enable DC 24 V (-15% / + 20%) 35 mA without load DC 5 V 300 mA 1 x 32 bits data 1 x 8 bits control / status DC 24 V 0.5 A short-circuit protected DC -3 V ... +5 V DC 15 V ... 30 V Latch 5 mA, Gate 7 mA, Ref. 7 mA CAGE CLAMP 0.08 mm ... 2.5 mm / AWG 28 ... 14 8 ... 9 mm / 0.33 in 24 mm approx. 105 g acc. to EN 50082-2 (1996) acc. to EN 50081-1 (1993)
1)
Also available individually Item no. 248-501 see pages 214 ... 215 Pack. unit 5
Accessories
Miniature WSB Quick marking system plain with marking
Approvals
Series 750 r UL 508 4 EN 50021 4 r UL 1604 Conformity marking
Postfach 2880 D-32385 Minden Tel.: +49(0)571/887-0 E-Mail: info@wago.com Hansastr. 27 D-32423 Minden Fax: +49(0)571/887-169 www.wago.com