Above is the circuit diagram for a basic solar shed lighting circuit with three bulbs. This same circuit could be used for any type of bulb whether incandescent, CFL (3), or LED. You would just need to select an appropriate fuse and ensure that the connecting wires used are thick enough for the current which will flow through them.
An input voltage of 12.336 Volts and a total current through the circuit of 0.29 Amps. The total power consumption is rounded down to 3 Watts from its true value of around3.5 Watts. The 0.233 Ah is a measure of the amount of battery energy used during the 50 minutes the test circuit was run. With a peak current of under 0.3 Amps cheap bell wire can be used to connect the bulbs, switch, and fuse into the circuit since bell wire is rated for 1 Amp currents. A 1 Amp fuse should be used to protect the circuit from short-circuits.