ISO/IEC 7776:1995
ISO/IEC 7776:1995/Amd.1:1996
Information technology—
Telecommunications and information
exchange between systems—
High-level data link control
procedures—Description of the X.25
LAPB-compatible DTE data link
procedures
AS/NZS 3512:2000
This Joint Australian/New Zealand Standard was prepared by Joint Technical
Committee IT/1, Information Systems—Interconnection. It was approved on behalf
of the Council of Standards Australia on 21 September 1999 and on behalf of the
Council of Standards New Zealand on 20 September 1999. It was published on
10 January 2000.
Information technology—
Telecommunications and information
exchange between systems—
High-level data link control
procedures—Description of the X.25
LAPB-compatible DTE data link
procedures
Originated as AS 3512—1987.
Jointly revised and designated AS/NZS 3512:2000.
COPYRIGHT
© Standards Australia/Standards New Zealand
All rights are reserved. No part of this work may be reproduced or copied in any form
or by any means, electronic or mechanical, including photocopying, without the written
permission of the publisher.
Jointly published by Standards Australia International Ltd, PO Box 1055, Strathfield,
NSW 2135 and Standards New Zealand, Private Bag 2439, Wellington 6020
ISBN 0 7337 3023 X
ii
PREFACE
This Standard was prepared by the Joint Standards Australia/Standards New Zealand Committee
IT/1, Information Systems—Interconnection to supersede AS 3512 — 1987. This Standard is identical
with and has been reproduced from ISO/IEC 7776:1995, Information technology—Tele–
communications and information exchange between systems—High-level data link control
procedures—Description of the X.25 LAPB-compatible DTE data link procedures, and Amendment 1:
Modulo 32 768 and multi-selective reject option, which is bound at the back of this Standard.
The objective of this Standard is to give network designers a specification for the protocol between
data terminal equipment and data circuit-terminating equipment at the data link layer level using the
X.25 LAPB procedures.
The term ‘informative’ has been used in this Standard to define the application of the annex to which
it applies. An ‘informative’ annex is only for information and guidance.
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
ISO/IEC AS/NZS
9646 Information technology—Open 4103 Information technology—Open
Systems Interconnection— Systems Interconnection—
Conformance testing methodology and Conformance testing methodology and
framework framework
9646-1 Part 1: General concepts 4103.1 Part 1: General concepts
9646-2 Part 2: Abstract Test Suite 4103.2 Part 2: Abstract test suite
specification specification
ITU-T —
Rec. X.25 Interface between data terminal
equipment (DTE) and data
circuit-terminating equipment (DCE)
for terminals operating in the packet
mode and connected to public data
networks by dedicated circuit.
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
This is a free preview. Purchase the entire publication at the link below: