FTPS
HTTP
HTTPS
WEP2
TFTP
2
Refer to the exhibit. A new branch office has been added to the corporate network and a new router is to be installed
branch office users to access the database server at headquarters. How should the serial 0/0/0 interface of the new b
office router be configured to connect to the headquarters router?
4 A new network is to be configured on a router. Which of the following tasks must be completed to configure this interf
implement dynamic IP routing for the new network? (Choose three.)
Update the ip host configuration information with the device name and new interface IP address.
Configure the routing protocol with the new interface IP address and subnet mask.
Configure the routing protocol in use on all other enterprise routers with the new network information.
5 How does TCP ensure the reliable transfer of data?
If data segments are not received from the source, the destination requests that the segments be resent.
If an acknowledgment of the transmitted segments is not received from the destination in a predetermined amount o
time, the source resends the data.
TCP uses the SYN-ACK portion of the three-way handshake to ensure that all data has been received.
The TCP Protocol Interpreter process verifies the transmitted data at source and destination.
6 A network administrator is asked to design a system to allow simultaneous access to the Internet for 250 users. The I
this network can only supply five public IPs. What can be used to accomplish this task?
routable translation
dynamic translation
static translation
BGP
RIP
OSPF
EIGRP
8
Refer to the exhibit. The network administrator needs to configure the router with a name. Which command will the
administrator use to configure the router name?
to indicate the correct router interface that should be used to forward a segment
to allow the receiving host to assemble the packet in the proper order
to select the paths that are used to direct traffic to destination networks
The debug ip rip command displays RIP routing activity in real time.
The debug ip rip command can be issued at the user EXEC configuration mode.
The debug ip rip command displays a combination of the information that is displayed by the show ip rout
show ip protocols commands.
Because of router processor usage, the debug ip rip command should be used only when necessary.
The debug ip rip command should be used instead of the show ip route command whenever possible.
12 What minimum configurations must be set on a host to allow a request to be sent to http://www.cisco.com/? (Choose
DNS server
WINS server
IP address
NetBIOS
subnet mask
default gateway
13 A Catalyst 2960 switch has been taken out of storage to be used as a temporary replacement for another switch that
be repaired. About a minute after the switch has started, the SYST LED on the front of the switch transitions from blin
green to amber. What is the meaning of the amber SYST LED?
The switch has failed POST and must be sent for service.
transport
network
data link
physical
is responsible for breaking messages into segments and reassembling them at their destination
17
Refer to the exhibit. The network shown is connected using services from the same ISP. How will the Fohi router dynam
learn routes to the 192.168.16.16/28, 192.168.16.32/28, and 192.168.16.64/28 subnetworks?
with BGP
18
Refer to the exhibit. Which type of UTP cable should be used to connect Host A to Switch1?
rollover
console
crossover