pressure or under a static head for future distribution by pneumatic or gravity means. Materials are PVC, G.I., reinforced concrete, stainless steel or plain steel.
A . B . C . D .
C .
D .
Q.5)
A . B .
Q.2) fluid may be withdrawn using manual or mechanical means such as draw bucket,pump,etc.
A . C .
B . C . D .
D .
Q.6) Water is sprayed into the air to release any trapped gases and absorb additional oxygen for better taste.
A . B . C . D .
Water Supply Distribution System Sanitary Drainage and Disposal System Storm Drainage System Electrical Piping System all of the above
Q.4)
Water is purified by ___________. In various processes, so as to remove the particles of vegetable matter, mud and Q.7) other particles of matter present in the water, most commonly used materials are sand and gravel.
A . B . C
A . B
Plumbing 1
ation
Q.8) water is passed through layers of sand and gravel in concrete basins in order to remove the finer suspended particles.
A . B . C . D . A . B . C .
underground container for waste matter: a covered underground tank or well for the collection of waste matter and water, especially sewage. CIST ERN SUMP PIT/ CESSPOOL SEWAGE TANK
Turbidity is another problems of water for water distribution, because Silt or mud Q.13) in surface or in ground, which can cause of discolation of water and bad taste, what is
Q.9)
A . B . C . D .
D .
Q.10)
Use extreme water pressure so as not to affect existing foundation in the vicinity. It makes use of a suction pump above, while casing acts as the pump riser. Q.14)
A . B . C .
A . B . C . D .
put noise reduction insulation to absorb noise that will be created by the pipes an additional 0.30m to 0.90m length of pipe is added to the riser to give air pressure which absorb it. addtional vent pipe
1. 2. To insure no leakage, a G.I. pipe when threaded has to use lead liquid or______ tape around the thread before tightening the fittings.
Q.15)
UNPLASTICIZED POLYVINYL CHLORIDE pipe PLASTICIZED POLYVINYL CHLORIDE pipe POLYVINYL CHLORIDE pipe
A . B
Q.12)
so lv en t t
Plumbing 1
C . D .
D .
soil bearin g
This is a kind of pump attached to the end Q.19) of deep well pipe enclosed in a casing where the pump is capable of functioning while submerged.
A . B . C .
Q.16) This water source is often in springs and wells as a source of water
A . B . C . D .
This consists of a wedge-shaped plug which is screwed down to seat between two brass rings surrounding
Q.20) the inlet pipe so that a double seal is
obtained. The inlet and outlet are in a straight line. This valve is used when a normal fully open or closed position is desired. Either end may be used as inlet
A . B . C .
Q.17)
excess water must be pumped away from a particular area. a pump used to remove water that has accumulated in a water collecting sumppit,
A . B . C . D .
Q.18)
A .
B .
C .
aq uif ers w e l l ci st e r n
3
Q.21)
3. These valves are used when it is desired that the flow through a pipe be always in one direction and there is a possibility of a flow taking place in the opposite direction. One type has a pivoted flap which is readily pushed open by the pressure of water from one side but is tightly closed by the force of a reverse flow.
A . B . C
Plumbing 1
valves
A . B . C .
These are dug with earth augers are usually Q.22) less than 30 meters (100 ft) deep. The diameter ranges from 2 to 30 inches. The well is lined with metal, vitrified tile or concrete.
A . B . C . D .
Q.26) The other physical properties of water is ability to climb up a surface against the pull of gravity
A . B . C . D .
There is a septic tank installed on the top of Q.23) a rock by the seashore. the tank is exposed on low tide, and covered in sea water during high tide. which of the following would be an appropriate water proofing for it.
A . B . C . D .
Q.27)
water proof all surface, exterior and interior water proof all interior surface except the floor water proof the walls only exterior and interior non of the above
A . B . C . D .
suspended solids are removed from the There are several reasons why soil stacks Q.24) are not allowed in columns. Which is NOT the reason?
A . B . C . D .
Q.28) water by gravity settling and deposition water is passed through basins so sediments can settle through a period of time
A . B . C . D .
Pipes will interfere with reinforcing Bars The size of the columns will be larger Cracks and leaks cannot be detected The Gas emitted will deteriorate concrete
Q.29) Q.25) The pipe from the public water main Requires more elaborate equipment depending on the geology of the site. Used for drilling oil and can reach up to
Plumbing 1
Q.30)
Q.34)
Plays an important part in the plumbing system, providing this is the most critical utility requirement, and also known as a "Universal Solvent"
A . B . C .
A .
B .
of tiny sieves (strainers) and exposed to air of fine mist to purify it.
A . B . C .
C . D .
Q.35) physical process in which the sediment particles collide with each other and stick together.
A . B . C . D .
Q.32)
Pump having a plunger that move back and forth within a cylinder equipped with check valves.The cylinder is best located near or below the ground level.
A . B . C . D .
pA ________is a device used to move Q.36) fluids, such as liquidsor slurries. A MECHANICAL EQUIPMENT displaces a volume by physical or mechanical action.
A
P U
Plumbing 1
B . C . D .
Jet pumps are centrifugal pumps typically used for drawing water up from a well.
A . B . C . D .
Q.37)
3. One end is 0.30M and the other end is 0.90M long. This prevents the pipe from snapping (breaking?)when the soil settles. [Ushaped?]
A . B . C . D .
It contains an impeller mounted on a Q.42) rotating shaft. The rotating impeller increases the water velocity while forcing the water in to a casing thus converting the waters velocity into higher pressure.
A . B . C . D .
National Masteral Plumbing Association of the Philippines National Master Plumbers Associations of the Philippines National Master Plumbing Associate of the Philippines non of the above
Q.39) method of introducing a controlled amount of chlorine to the water in order to attain a desired degree of disinfection.
A . B . C . D .
is the art and technique of installing pipes, Q.43) fixtures and other apparatuses in buildings & bringing the the supply liquids substances &/or ingredients and removing them
A . B . C .
Q.40)
Plumbing 1
D .
is plumbing system which carries water Q.44) from the water source, street main or a pump to the building and to the various points in the building at which water is used
A . B . C . D .
case the city main is temporarily shut off. The pipe from the pump to the tank should be across connected to the city main so that the water may be pumped directly from the main in case of fire. These tanks are used so that the pneumatic tank or other pumps suck the water from this tank and not from the public main, so that it will not deprive the neighbors of water due to pressure.
A . B . C . D .
Sewage System Water Supply and Distribution System Drainage System Non of the above
Q.45)
Is basically a centrifugal pump complete with electric motors which are positioned under water in a suitable bored hole that delivers the water to the surface
A . B . C . D .
is a pump used to deliver water at a point higher than the position of the pump itself. When the plunger (a piston) Q.48) descends, valve A is closed and water in the cylinder is forced out through valve B and up to the storage. When the plunger is raised, valve B is closed and A open to admit water to the cylinder. [A pump that uses pressure to move liquid]
A . B . C .
Q.46) is any method that will remove one or more materials that make the water unsuitable for a given use
A . B . C . D .
Water Sedimentation Water Treatment Water boiling non of the above is a tank constructed of riveted or welded steel plate; the larger tanks often being divided into two compartments. They should be large enough to contain at least one days supply for the entire building in
7
Is a positive displacement reciprocating Q.49) pump in which a plunger is driven backwards and forwards, or up and down by a mechanical working head. Water is sucked into a sealed vacuum by use of a piston.
A . B . C . D .
Q.47)
Q.50)
Plumbing 1
In 1935, this the only group/ organization for plumbing works and ordinaces
A . B .
C .
D .
NA MPA P N AP AP D I L G D E N R
Q.54) chemical process in which the coagulant reacts with the sediment to make it capable of combining into larger particles.
A . B .
Hardness is another problem for water Q.51) distribution because of Presence of magnesium and calcium salts, which can cause Clogging of pipes Impaired laundry and cooking, which is the best solution for this?
A . B . C . D .
C . D .
COAGULA TION FLOCCULA TION SEDIMENTA TION AERA TION A_______ is water equipment used whenever the water supply at its natural pressure cannot be directly piped to a building, tank or reservoir. p u m p t a n k m o t o r b i b b
Q.55)
A .
B .
Q.52) g1. A fitting installed at a branching tee from a horizontal soil branch to a horizontal waste branch.
A . B . C . D .
C .
A. 4x2 Wye and 2 1/8 bend combination B. 4x4 Tee C. 4x2 Tee D. 4x4 Wye and 4 1/8 bend combination
D .
Q.56) and
Q.53)
A .
the horizontal pipes that serve the faucets are called _______
bra nch
Plumbing 1
B .
C .
D .
D .
Q.60) A turbine pump ha s a vertical turbine located below ground water levels and a driving motor located at ground
A . B . C . D .
CENTRIFUGAL PUMP RECIPROCATING PUMP TURBINE PUMP SUBMERSIBLE PUMP A tank using air pressure from a suction tank to distribute water for tall buildings which cannot be reached by normal pressure. WATER TANK CISTERN TANK SUCTION TANK PNEUMATIC TANK
1. 2.
Q.61)
A . B . C . D .
Q.58)
A . B . C . D .
Water is soft & pure and is suitable for the hot water supply system Water is available everyday Water that is natural and purified by natural means non of the above
Q.62)
3. A stop valve in a service pipe close to its connection with a water main.
A . B . C . D .
Acidity is one of the most problems in Q.59) water distribution and water purification, which can cause Corrosion of nonferrous pipes and Rusting & clogging of steelpipes, which is the best solution for this problem?
A . B . C .
Passing the water through a bed of crushed marble or limestone to achieve alkalinity, or adding sodium silicate.) Chlorination for removing salt contents Aer atio n
9
Q.63) of the pipe section and driven into the earth.The point may be driven into the ground to a depth of up to15meters(50ft).
A . B .
Plumbing 1
C . D .
. D .
a pump consist of a piston traveling up and down within a cylinder which is connected with a pipe extending
Q.64)
A .
down into the source. The piston and the bottom of the cylinder are each provided with a valve opening upward. Upon the pistons upstroke, valve A closes and valve B opens. Upon the pistons down stroke valve A opens and lift pu mp submersible pump force pump
C . B .
A . B . C .
bu shi ng re du ce r f i t t i n g
A kind of G.I. fitting that has one end external threads, while the other end has internal threads.
Q.68)
A .
Q.65) A mixture of surface run-off and ground water. Surface sources includes rivers, lakes, ponds and impounding reservoirs.
A . B . C . D .
B .
C .
Q.69) Which of the following locations DO NOT require installation of a clean out?
A method of purifying water wherein particles of matters that are suspended in Q.66) the water are allowed to stay in a container so that they will settle in the bottom, then drawing the water out, leaving these matters in the container.
A . B . C
A. At every branch interval of a soil stack B. Any horizontal waste or soil pipe exceeding 15 meters C. Any change in direction of a soil branch 22.5 degrees and over D. At every end of every soil branch
Q.70) Which in the list is NOT a standard commercial size of GI pipe for water supply?
Plumbing 1
diameter
Q.71)
Which criterion is NOT needed in sizing a vent pipe for individual, branch and circuit vent based on the total linear footage of the pipe making up the vent?
Q.77) What is a GI fitting to join two threaded fittings as close as possible but not exceeding 3 inches?
A. Developed length of the vent pipe B. Number of fixture unit C. Slope of the drain pipe D. Size of the drain pipe
Q.72) Where are dampers installed to regulate the amount of cool air for an even distribution to outlets?
A. Fire Department House Connection B. Combination Standpipe C. Dry Standpipe D. Wet Standpipe
What is a device installed on top of a pressure tank used to protect against hydrostatic collapse due Q.79) to suction or negative pressure resulting from back-siphonage in a downfeed water distribution system?
A. at the trunk ducts B. at a practical location at angles and elbows C. at the branch supply duct as far as practical from the outlet D. at the air boot fitting
Q.73) What is the size of supply valve for tank type water closet?
A. pressure reducing valve B. vacuum breaker valve C. air volume control valve D. pressure relief valve
Q.80) What does PE pipe stands for?
A . B . C . D .
A. polyethylene pipe B. polythylene pipe C. polyvinyl extra pipes D. plastics extra pipe
Water as delivered by NAWASA is no longer safe for drinking because of several contaminants from the water source present in the environment. It is now therefore imperative that water to be safe for drinking has to undergo Q.81) water purification in several stages. Because of several contaminants, water undergoes several stages. What is a stage in water purification, which removes mineral deposits, salts, heavy metal, totally dissolves solids while some useful minerals are retained?
Plumbing 1
osmosis
Q.82) The term used to the main water pipe delivering potable water to a building is called
A. storeroo m B. inside a mechanical/electrical room C. a landing of an enclosed stairway D. at any private room or rentable space
Q.88) The general term for the hot or cold water pipes containing potable water
A. water plumbing pipes B. water distribution pipes C. hot or cold water line D. water supply pipes
Single lever valves used in kitchen sink and lavatory faucets or at shower valves has gain Q.89) popularity in plumbing installation today. This is because these valves are beautiful and are maintenance-free. These valves work by the principle of a:
12
Plumbing 1
Q.95)
Any pipe in the plumbing system provided to ventilate a house drainage system and to prevent trap siphonage and back pressure.
A. On every hose bibb B. On water supplies to pressurized tank C. On the water service pipe near the source connection D. On the main water distribution pipe near the water service
In a water system with constant water supply supplying series of plumbing fixtures, water Q.92) supply drop is experience when the fixtures in the series are simultaneously opened. Which poor design in the plumbing system causes this?
A. Choice in the system of water distribution B. Insufficiency in the size of the water service and distribution pipe C. Too many fixtures opened simultaneously D. Use of PVC or other plastic pipes
Q.93)
In a water distribution system, locations such as supply pipe to every water heater requires a full open valve. Which of the following in the list is a full open valve?
A. for convenience in installing the pipe B. to facilitate air movement with lesser air resistance C. for purposes of economy D. to allow any waste to drain into the drain pipe
13
Plumbing 1
Q.107) A female GI pipe reducer fitting used in a straight pipe connection where the fittings both ends are threaded inside
A. Over loaded fixture unit in the soil stack B. Change in the atmospheric pressure in the
14
Plumbing 1
A. Pressure relief valve B. Pressure reducer C. Pressure reducing valve D. Pressure regulator . By gravity, water is distributed from overhead water tanks and is supported either by structural frames or on the roof decks. Fixtures are below the gravity Q.109) tank. These elevated tanks are installed when normal water supply from main public service pipes is not frequent and when normal pressure from city main is not enough to force the water to the highest fixtures.
A . B . C . D .
DAM . Water is treated by giving ________________ to kill the Q.112) harmful bacteria present and to cure the turbid taste or mud taste, remove clay, salts, iron, etc. commonly used treating liquids is chlorine.
. A . B . C .
chemical powder chemical treatments ba cte ria . The vertical supply pipe which
UPFEED SYSTEM DOWN FEED SYSTEM PRESSURE SYSTEM DIRECT SYSTEM . Water is distributed from the normal water pressure coming from the public water main, for low rise buildings.
B .
C . D .
Q.110)
UPFEED SYSTEM B DOWN FEED . SYSTEM C PRESSURE . SYSTEM D DIRECT . SYSTEM . Q.111) A reservoir, tank or vessel for storing or holding water or other liquids
A . A . B . C . D
Q.114)
power tools -depth of about 15 meters (50 ft) -can have the greatest diameter that a space may allow
A . B . C . D .
Plumbing 1