http://www.4shared.com/rar/Xam-iQu2/Lab-13-Operating__Initial_Conf.html 1) 2) 3) 4) 5) 6) Configure the topology Initial Configuration (Setup Mode) Configuring Security on Router Configure Routers Loopback Address Configuring Interface IP Addresses Configuring Clock Rate & Bandwidth for Serial Interfaces
Select the router c7200 from the node types and place next to SW1 as shown above. To rename router, Right click the router and select Change the hostname. Right click router and select Configure. At slots tab add C7200-IO-FE (Fast Ethernet) module to slot 0 and PA-8T (Serial) module to slot 1. Click Apply and Ok. Select Manual from the Add Link button at toolbar and connect the router fa0/0 interface to the SW1 fa0/15 interface. Start the switch and router.
www.asghars.blogspot.com
ii.
www.asghars.blogspot.com
ii.
www.asghars.blogspot.com
To find which router has the DCE cable in it, you can find out by using the show controllers command.
www.asghars.blogspot.com
www.asghars.blogspot.com