Description
TCP/IP protocol suite is used for ____________. Addressing and Routing services Enhanced and Reliable communication Terminal Emulation File transfer between different systems.
________acts as source and destination for IP traffic. Interface Node Host Router
___________ protocol is used to send messages and attachment of mails. File Transfer Protocol (FTP) Simple Mail Transfer Protocol (SMTP) Transfer Mail Protocol (TMP) None of the above.
1546 Which of the following defines a family of standards for 100 Mbps fiber optic LANs that provides the physical layer and media access control sub-layer of the data link layer, as defined by the ISO/OSI Model? Ethernet IEEE 802 Fiber Distributed Data Interface (FDDI) Point-to-Point Protocol (PPP) Within the Frame Relay frame format, which of the following is used for aligning data bits? Q.922 field Pad field UI (0x03) field NLPID field
10
Which of the following protocol resolves a host's hardware address for a known IP address? InATMARP protocol ATMARP protocol InARP protocol ARP protocol Which of the following is merely a packet framing protocol?
11
13
14
Strict source routing Loose source routing Record Route Internet time stamp 15 Which class of IP addressing are used for multitasking with a limited area? Class D addresses Class C addresses Class B addresses Class A addresses Which component of the ICMP message format is used to detect if another host is active in the network through the Ping command? Type Checksum Code Echo Which of the following protocols will not make use of ICMP messages to give information about errors?
16
17
19
21
Which of the following provides the service for any casting? IPV5 IPV6 IPV7 IPV8
22
Which class of IP addressing was not brought in much use? Class Class Class Class A addresses D addresses B addresses C addresses
23
Which of the following network addresses can accommodate 65,334 hosts? Class A addresses Class D addresses Class B addresses Class C addresses Which of the following use default routes for interdomain routing? Type 2 Type 4 Type 3 Type 1 The range of well known ports lie between ___ and _____. 1 1 2 1 and and and and 1023 1024 1023 1022
24
25
26
Which layer use User Datagram Protocol (UDP) and Transmission Control Protocol (TCP)? Network layer Physical layer TCP/IP transport layer Data link layer Which of the following protocols has STD number 6? Transmission Control Protocol (TCP) User Datagram Protocol (UDP) Address Resolution Protocol (ARP Internet Control Message Protocol (ICMP)
27
28
Which of the following does not ensure reliability of datagram? Transmission Control Protocol (TCP) Internet Control Message Protocol (ICMP) Address Resolution Protocol (ARP User Datagram Protocol (UDP)
29
What is the maximum size of IP header in the UDP Datagram format? 40 50 60 70 bytes bytes bytes bytes
30
Which of the following is connection-oriented protocol? User Datagram Protocol (UDP) Transmission Control Protocol (TCP) Reverse Address Resolution Protocol (RARP) Internet Control Message Protocol (ICMP) Which of the following protocols is developed by Cisco systems? Exterior Gateway Protocol (EGP) Enhanced Interior Gateway Routing Protocol (EIGRP) Border Gateway Protocol (BGP) Static routing protocols Which of the following dynamic routing protocols discuss about Shortest-Path First (SPF) algorithm? Path Vector Routing Link State Routing Distance Vector Routing Hybrid Routing
31
32
33
_________ is the protocol based on Xerox XNS routing protocol. Exterior Gateway Protocol (EGP) Routing Information Protocol (RIP) Border Gateway Protocol (BGP) Static routing protocols What is the maximum size of RIP packets? 64 octets
34
35
Which of the following is an example of hybrid routing protocol? Border Gateway Protocol (BGP) Exterior Gateway Protocol (EGP) Enhanced Interior Gateway Routing Protocol (EIGRP) Open Shortest Path First (OSPF) Which of the following protocol is described in RFC 4271? Border Gateway Protocol (BGP) Routing Information Protocol (RIP) Enhanced Interior Gateway Routing Protocol (EIGRP) Open Shortest Path First (OSPF) What is the STD number for File transfer protocol? 7 9 8 10 In File transfer protocol, which server port is used for data connection? 18 19 20 21 In FTP, to execute a file transfer, the user begins by _________. Navigating the directory structure Connecting to a remote host Listing files available for transfer. Defining the transfer mode While connecting to the remote host in FTP, the command used to authenticate the user is _______. Open User Site Pass
36
37
38
39
40
41
In case of Trivial File Transfer Protocol, which command is used to retrieve a file? Get <remote filename> [<local filename>] Mode <ascii|binary>
Put <remote filename> [<local filename>] Connect <host> 42 The opcode for "Read Request" operation used by Trivial File Transfer Protocol is _________. 2 1 3 4 Which of the following is based on end-to-end delivery? File Transfer Protocol (FTP) Simple Mail Transfer Protocol (SMTP) Post Office Protocol (POP) Internet Message Access Protocol (IMAP4) The general form of the SMTP destination address is ________________. user% remote-host@gateway-host user@host local-part@domain-name None of the above Which of the following filed represents the sender of the message in an electronic mail? To From cc Reply-to What is the standard STD number of Post Office Protocol (POP)? 51 52 54 53
43
44
45
46
47
The older Post Office Protocol (POP) version 2 is described in RFC ________. 937 1959 4250 959 In which of these states in IMAP4 does the client has to select a mailbox to proceed? Authenticated state Non-authenticated state
48
Selected state Logout state 49 Which of the following is an audio data compression algorithm for voice? G.723.1 G.729 G.728 G.726 Which of the following request in Session Initiation Protocol (SIP) queries the capabilities of servers ? CANCEL ACK OPTIONS PRACK Which of the following response is used to denote server failure? SIP 4xx SIP 5xx SIP 2xx SIP 1xx Which of the following in SIP environment allows the receiver to detect packet loss? Resource Reservation Protocol (RSVP) Stream Control Transmission Protocol (SCTP) Real-time Control Protocol (RTCP) Real-time Transport Protocol (RTP)
50
51
52
53
What is the bandwidth requirement of Internet Protocol Television (IPTV)? 5 Mbps to 30 Mbps 6 Mbps to 31 Mbps 7 Mbps to 32 Mbps 8 Mbps to 33 Mbps Which of the following monitors the quality of service provided to existing RTP sessions? Resource Reservation Protocol (RSVP) Stream Control Transmission Protocol (SCTP) Real-time Control Protocol (RTCP) Real-time Transport Protocol (RTP)
54
55
Which of the following is sent by the source of an RTP data stream? Source description report APP
Receiver report Sender report 56 Which of the following was initially designed as a video and audio compression standard? MPEG-1 MPEG-2 MPEG-3 MPEG-4 H.261 allows sending still picture graphics with __________ luma resolution. 703x575 704x576 705x577 706x578 ___________ profile is used widely in video conferences and mobile applications. Main Profile (MP) Extended Profile (XP) Intended Baseline Profile (BP) High Profile (HiP) In flags message attribute, which of the following flag indicates that message has been completed? \Deleted \Recent \Flagged \Draft Which of the following attribute shows relative position of the message in the mailbox? Message sequence number message attribute Unique identifier (UID) message attribute Unique identifier attribute Flags Message attribute
57
58
59
60
Choice
A B C D
Solution
A B C D
A B C D B
A B C D
A B C D
A B C D A B C
A B C D
A B C D B
A B C D
A B C D B
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B
C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B
C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B C D
A B
C D
A B C D
A B C D
A B C D
A B C D
A B C D