Page 1 of 4
Send to friend
Normal Search | Advanced Search > [Physical Properties>Treatability (amenability to preservative treatment)>Difficult ]
INTRODUCTION The Standard Malaysian Name for the dark red and lightweight timber of the genus Shorea (Dipterocarpaceae). Vernacular names used include meranti (Peninsular Malaysia and Sarawak) with various epithets, seraya (Sabah) with various epithets, nemesu (Peninsular Malaysia), nemusu (Peninsular Malaysia), seraya (Peninsular Malaysia and Sabah), obar suluk (Sabah) and also various local names too numerous to list here. Major species producing this timber include S. acuminata (partly), S. argentifolia, S. curtisii, S. ovata, S. monticola, S. pauciflora, S. platyclados and S. slootenii.The sapwood is pink with a grey tinge and is not clearly defined from the heartwood, which is medium red to deep red to deep red-brown. Also known as Dark Red Meranti (Brunei); Meranti ketuko, Meranti Merah and Meranti merah tua (Indonesia); Dark red Lauan, Dark Red Philippines Mahogany, Mayapis,Red lauan, Tangile and Tiaong (Philippines); and Saya and Saya-Daeng (Thailand). DENSITY The timber is a Light Hardwood with a density of 415-885 kg/m3 air dry. NATURAL DURABILITY The standard graveyard tests on untreated specimens carried out by the Forest Research Institute Malaysia (FRIM) have classified dark red meranti as moderately durable with an average service life ranging from about 2.0 years (S. singkawang) to 3.9 years (S. platyclados). For the species S. curtisii, S. pauciflora, S. platyclados and S. acuminata, the heartwood is classified as moderately durable (with an average service life of 2-5 years). Similar tests on S. pauciflora at Princess Risborough (U.K.) have indicated that the timberis moderately durable with a service life of 10-15 years (under temperate conditions). The sapwood of dark red meranti is susceptible to dry-wood termite attacks, which may eventually spread to the heartwood. However, an initial invasion of the heartwood is less likely to occur. Untreated timber of S. curtisii was only slightly attacked by marine borers after eight months submergence at Port Klang (Thomas, 1933). Preliminary work done by Oliver & Woods (1957, 1959) have tentatively classified dark red meranti as resistant to such attacks. PRESERVATIVE TREATMENT The timber is difficult to treat with preservatives. Generally, it was found that all forms of meranti (including dark red meranti) absorb less preservative than
http://woodwizard.mtc.com.my:8888/report.asp?AttrID=82&ItemID=103
1/23/2013
Page 2 of 4
kempas and keruing when subjected to identical treatments. TEXTURE Texture is moderately coarse and even, with interlocked grain. STRENGTH PROPERTIES The timber falls into Strength Group C (Engku, 1988b) or SG 5 (MS 544:Part 2:2001). Strength Properties of Dark Red Meranti
Test Modulus Modulus Compression Compression Shear of parallel to perpendicular strength Condition of Elasticity Rupture grain (MPa) to grain (MPa) (MPa) (MPa) (MPa) S. Green 10,500 54 27.4 2.41 6.3 acuminata Air dry S. curtisii Green 12,800 69 36.3 3.86 7.2 Air dry 13,900 90 45.4 5.03 8.0 S. Green 12,700 71 37.7 3.45 7.5 pauciflora Air dry S. Green 11,300 58 30.0 2.69 6.3 platyclados Air dry 12,100 77 39.6 4.14 8.7 S. Green 10,100 55 31.8 3.03 7.6 singkawang Air dry 11,200 74 38.8 2.97 8.3 Species
MACHINING PROPERTIES It is easy to saw and work and produces a smooth planed surface. Machining Properties Dark Red Meranti
Species Test Condition Sawing Planing Boring Ease of boring easy easy Turning
ReCross Ease of Quality of sawing Cutting planing finish easy easy easy easy easy easy smooth smooth
Quality Ease of Quality of of turning finish finish smooth smooth easy moderately smooth
Green
easy
easy
easy
smooth to slightly smooth moderately smooth smooth smooth smooth smooth smooth smooth
easy
smooth
Air dry S. pauciflora S. platyclados Green Air dry Green Air dry S. singkawang Green Air dry
moderately smooth easy moderately smooth easy easy easy rough slightly rough
NAILING PROPERTY The nailing property is rated as good. AIR DRYING The seasoning properties of some species tested are summarised below:
Species Time to air dry (months) 13 mm thick 38 mm thick Remarks
http://woodwizard.mtc.com.my:8888/report.asp?AttrID=82&ItemID=103
1/23/2013
Page 3 of 4
boards 3 4 4 5 Fairly fast drying; seasoning defects. Fairly fast drying; seasoning defects. Fairly fast drying; seasoning defects. free free free from
from from
KILN-DRYING Kiln Schedule F is recommended. The timber dries rapidly without any degrade. Kiln Schedule F
Moisture Content (%) Temperature (Dry Bulb) F Green 60 40 30 25 20 10 120 120 125 130 140 155 170 C 48.5 48.5 51.5 54.5 60.0 68.0 76.5 Temperature (Wet Bulb) F 111 109 109 109 115 124 136 C 44.0 43.0 43.0 43.0 46.0 51.0 58.0 Relative Humidity (%) (approx.) 75 70 60 50 45 40 40
MOVEMENT IN SERVICE The movement of seasoned timber is classified under Type I and Type II. DEFECTS All timbers in the meranti group are liable to be attacked by shot-hole and pin-hole beetles, but the attack is usually not serious in species of dark red meranti. Although most of these attacks take place in the living trees, any delay in extraction after felling may also lead to serious damage. Spongy heart is a common defect in the red meranti group. Timber with this defect is exceptionally brittle and may result in compression failure and the corresponding reduction in strength properties. In a study of logs of dark red meranti and light red meranti from Perak state, about 30 logs of seraya (S. curtisii), over 40 logs of nemesu (S. pauciflora) and more than 100 logs of light red merantiwere found to contain varying degree of spongy heart. This presence of spongy heart was less severe and also less spread in dark red meranti than in light red meranti . But large sized logs of dark red meranti (both seraya and nemesu) tend to rot away at the centre leaving a hollow core with active termite attack on the fringes (Mohd. Alwy, 1961). One prominent feature of dark red meranti is the presence of exceptionally numerous and conspicuous lines of resin canals, which may be objectional to some user. Small resin pockets are present but they are seldom numerous. One case was noted in which abnormally large horizontal resin canals in S. ovata marred the appearance of the sawn timber. USES
http://woodwizard.mtc.com.my:8888/report.asp?AttrID=82&ItemID=103
1/23/2013
Page 4 of 4
The timber is suitable for joinery, furniture, high class interior finishing, flooring, decking, panelling,partitioning, mouldings, skirtings, fancy doors, door and window frames and sills, staircase (angle blocks, rough bracket and tread), plywood, railway sleepers, posts, beams, joists, rafters, pallets (expendable type), vehicle bodies (framework, floor boards and planking), ship and boat building (keels, keelsons, framework and general planking), cooling tower (non structural members) and other light constructional works. REFERENCES 1. Choo, K. T. & Lim, S. C. 1982. Malaysian Timbers Dark Red Meranti. Malaysian Forest Service Trade Leaflet No. 69. The Malaysian Timber Industry Board and Forest Research Institute Malaysia, Kuala Lumpur. 14 pp. 2. Engku Abdul Rahman Chik. 1988b. Basic And Grade Stresses For Some Malaysian Timbers. Malayan Forest Service Trade Leaflet No. 38. The Malaysian Timber Industry Board And Forest Research Institute Malaysia, Kuala Lumpur. 13 pp. 3. Menon, P. K. B. 1986. Uses of Some Malaysian Timbers. Revised by Lim, S. C. Timber Trade Leaflet No. 31. The Malaysian Timber Industry Board and Forest Research Insitute Malaysia, Kuala Lumpur. 48 pp. 4. Mohd. Alwy bin Hj. Sulaiman. 1961. Report on Forest Administration For The Year 1961. Federation Of Malaya Forestry Department, Malaya. 5. MS 544: Part 2: 2001: Code Of Practice For Structural Use Of Timber. Permissible Stress Design of Solid Timber. 6. Oliver, A. C. & Woods, R. P. 1957 & 1959. First and Second Reports ona Study of The Natural Resistance of Certain Timber Species to Marine Borers. T.D.A. 7. Redding, L. W. 1971. Resistance of Timbers to Impregnation with Creosote. For. Prod. Res. Bulletin No. 54. H.M.S.O. London. 8. Thomas, A. V. 1933. Marine Borer Tests in Malaya. Mal. For. 11. pp. 179. 9. Wong, T. M. 1982. A Dictionary of Malaysian Timbers. Revised by Lim, S. C. & Chung, R. C. K. Malayan Forest Record No. 30. Forest Research Institute Malaysia Kuala Lumpur. 201 pp.
If you have any queries about MTC Wood Wizard, please write to woodwizard@mtc.com.my Copyright 2006 Malaysian Timber Council 18th Floor Menara PGRM, 8 Jalan Pudu Ulu, Cheras 56100 Kuala Lumpur, Malaysia Tel: +603-9281 1999 Fax: +603-9282 8999
http://woodwizard.mtc.com.my:8888/report.asp?AttrID=82&ItemID=103
1/23/2013