Anda di halaman 1dari 4

EST Module 27

KEYWORD
Typical temperature dispersion of fiber Bragg grating Critical diameter at 1550 nm Cut-off wavelength of single mode optical fiber in nm Typical single mode core diameter Typical cladding diameter of commercial optical fiber Typical core diameter of multimode step-index fiber To increase bandwidth high temperature Known notoriously for its high leakage current Optical power split to more than two outputs Theoretical bandwidth of optical fiber reported the past 10 years Loss of glass-to-air interface Refractive index change only in boundary of core cladding Cover jacket of multimode Maximum pigtail length may produce hazardous fumes if the material is made of ______ In flexible endoscope18,000 fiber Benefits of using optical fiber Fiber optic in the 1980s Area illuminated by optical sources

ANSWER
-0.011 dB/km 1100 nm 110 1280 9 -10 um 125 um 50 1000 microns Edge-emitting LED Ge PIN Tree coupler 100 THz 4% Step-index Orange 1000 mm Beryllium oxide ceramic 11.6 um 0.5 dB/km 62.5/125 Launch spot size

KEYWORD
Erbium spectral density Critical diameter for single mode fiber at 633 um wavelength Low loss region in fiber optics Typical cladding diameter of single mode fiber Typical multimode glassoptical fiber cladding diameter Silicon PIN diode quantum efficiency Used if high responsivity is required Maximum axial misalignment to maintain 0.3 dB loss Optical power split evenly to two outputs soot Great effect in insertion loss Core refractive index gradually change form middle of the fiber Fundamental mode, V value Low loss and long wavelength Added in optical fiber during manufacturing for low and long wavelength In flexible endoscope8.9 um Erbium Doped Fiber Amplifier (EDFA) laser pump Fiber connector insertion loss must be ____ Which is not true about fiber optic

ANSWER
-41.3 MHz/C 450 1150 1350 125 um 1253 um 95% InGaAsP 5% Y coupler Metal halide, dopant materials and oxygen Numerical aperture mismatch Graded-index Less than or equal to 2.405 Heavy metal fluorides Silver bromide 10,000 fibers 980 nm Below 1 dB It provides no security because the signal is easily intercepted. 510 nm 900 um 2.1 Mbps 5 times

Maximum tensile load for lashed aerial cable Laser lines of Gallium arsenide Bluetooth maximum data rate Bluetooth + EDR(enhanced

300 lbs 800 1700 721 kbps 3 Mbps

Laser lines of argon In buffered with polyester elastomer Bluetooth + EDR(enhanced data rate) practical data rate Home RF

data rate) nominal data rate 802.11b (WiFi) Class I Bluetooth power Capacitance minimum voltage Gain of three-dipole array with negligible spacing 85.6x53.98mm (used in ATM cars, credit card, debit card, ect) Type A and type B proximity card communicate using this frequency Omega global coverage GPS, PPS (precise positioning service) GPS channel high precision military use GLONASS center frequency In TACAN navigation system, rotating antenna in ground system (beacon) enables the aircraft to locate the beacon with _____ accuracy. Not requires in RADAR

Bluetooth range 10 time Bluetooth range 4-20 dB 3.3 dB ID-1 13.56 MHz 88%-98% 22.3 L2 1602.56-1615.5 1 Power classification of 0.25mW to 2.5mW Bluetooth Voltage is zero Rhombic antenna Long wave antenna above ground 125x88mm (used in passport and visa) mobile earth station Avionic, above ocean GPS, SPS (standard positioning service) NAVSTAR GPS center frequency Accuracy of DECCA increase accuracy Class 2 20 3 to 6 meters ID-3 INMARSAT-C AETOSAT 106.7 1575.42 and 1227.6 20 to 50m Geometric dilution of precision

always has 1% GPS/GLONASS update every _____ Terrain contour navigation (TCN) accuracy

The switch absorbs maximum power during Tx and Rx Doppler heading reference Daily 50m

Parameters of ephemeris

16

Not a passive user Update rate of GPS/GLONASS Using GPS receiver, military personnel using P code can determine his 3D velocity with ___m/s accuracy Gigabit Ethernet that can support 1000 Mbps 1000BaseLX drivenactuator Hue, saturation, brightness

VOR 1 sample/second 0.1

Can support any LAN type in a voice-grade UTP copper wire Generic term for fast Ethernet 10BaseT maximum length An inertial navigation systemmountedinertial sensors are connected directly to the vehicle frame. 100 IRE

100VG-ANY LAN 100BaseT 100m Strap-down approach

1000BaseT 550m Mechanized platform approach HVS

Reference white Optimal viewing distance 802.14 +20 to -20 Class I International exchange program by means of HDTV Powerof HDTV ___ less than (NTSC) Clock rate of widescreen HDTV Connectionless service,

Optimal viewing distance REC 741 12-18 dB 148.5 MHz Class II

For TV broadcasting IRE value for color burst sine wave peak Dedicated connection with

acknowledgement Class B FM contour distance Poor efficiency, poor frequency response, complex transmitter design Mode field diameter is being measured usingrecommendation Measurement of fiber optic point defect Multimode and single mode insertion loss is measured using ____ standard. Engineering task force IP standardization ITU standard that defines ADCCP Safety of the public and personnel working around RF equipments Not fully developed, with no own standards organization, informed with ISO works but does not contribute to standards promulgation. Two frequencies used by active RFID High fidelitydynamic range _____ bits. What happens to T-1 line sampling rate when used with ADPCM Number of device Bluetooth RF can support TCS bin Standard that defines CWDM DOCSIS upstream Bundled fibermedium density STS, base signal rate of SONET x-rayhazardous above__ Unique ID (DNC), DNIC is allocated to each subscriber using recommendation MEMS insertion loss Not true about OFDM (orthogonal frequency

52 km SSB+C

need acknowledgement Permissible power of class II-A nighttime Frequency spectrum efficient Reflectance measured using ____standard Transmission loss of fiber optic plant (multimode) Proximity card used for identification and transmission and protocol for communicating with it CCITT changed to ITU-T In telephone systems, they have the same bit rate With voting rights Frequency range of intermediate RFID

10-50 kW SSB-SC

EIA/TIA 455.167 EIA/TIA 455.59 EIA 455.34

EIA/TIA 455.107 EIA/TIA 526.14 ISO/IEC 14443

RFC 791 ANSI X3.28 ANSI C95.1-1991 Correspondent bodies

1993 V.29 and V.32 Member bodies 10-15 MHz

900 MHz, 2.4 GHz 16-24 It is reduced to its sampling rate. 127 Q.931 G.694.2 10 Mbps 24-72 51.84 15kV X.121

14,000ft ADSL(not possible) 16-24bits IP address 4 decimal numbers from 0 to ____ separated with dots Maximum length of firewire, if supporting 63 devices 12loose tube design referred to as______ Maximum transmission line characteristic impedance, including DOCSIS downstream Typical microwave IF frequency OFDM Not true about IrDA Coined Artificial Intelligence in 1956 RIP Outer diameter of Optical Fiber cable connection

4.096 Mbps 5Mbps 255 72m Ribbon design 600 ohms 27-36m\Mbps 30-60MHz 2,4 and 6 Interfere with other wireless devices John McCarthy

0.1dB It is standardize by

Bellman Ford algorithm 2mm

demodulation multiplexing) rule of thumb Morse Code Mean Time to Failure (MTTF)commercial laser at 22C Minimum conductivity waveguide made of brass Orthogonal carriers Bluetooth RF periodicity of the characteristic(channel hopping sequence) Disadvantage of using positioning system over INS and dead-reckoning system is that it cannot measure at frequencies higher than____ BidirectionalDOCSIS, ITU-T recommendation for transmission of TV, sound and other multimedia signal Standardization of digital storage media-command code Bandwidth of UWB(ultra wideband) If Bluetooth has 1Mbps speed, Home RF has ___speed UWB authorized unlicensed frequency range Which is not true about Frame User to Network Interface(FUNI) Reason why orthogonal frequency division multiplexing(OFDM) is preferred in terrestrial broadcasting From sensor tocard reader Number of fibersin OFCC

802.11b +4 to +6dBm G9.296 10^5 44.2% OFDM 23hours and 18minutes 100Hz

(OFCC) Wireless USB3.1-10GHz 110Mbps Frequency exposurehuman body can absorb Transit system accuracy advertise availability of optical resources in the network Packet over SONET(POS) has a minimum speed of ___Mbps NTSC modulation index if fiber optic is used in transmission Speed of wireless USB

10m 80-100MHz 500m Open Shortest Path First(OSPF) 155 0.25-0.33

480Mbps

J.112

Principal substance used which is in great preponderance of magnetic tapes. Optical gyroscope Number of wavelength in DWDM dish mountedin size of a pizza can receive signal up to___kbps Suitable for linking PC directly to telephone system. Power density in frequency range of 30300Mhz CWDM____wavelength gap between two adjacent channels. Polarity stability of fused biconical taper technology Hybrid fiber optic and cable systems(HFC)

Polyester

EIA/TIA 13818-6 >500MHz 1.6Mbps 3.1-10.6MHz

Sagnac effect 32-128 256-400 Telephone Application Programming System?(TAPS) 0.2mW/cm^2 20nm

It is a fast speed ATM Long symbol duration

Wiegand protocol Less than 36

0.1 dB 50-860

For Underground Movement ONLY

Anda mungkin juga menyukai