0+
Version 2 Description
The version 2 brings you a lot of new features and wants to be modable as you need depending of your Xbox.
These points concern Both SLIM and FAT These points concern SLIMs These points concern FAT (FAT1 & FATX For Xenon, FAT1 & FAT2 For other revisions) Choose your capacitor (270pF For Xenon, 330pF Or 390pF For Slims) Timings Configurations (Choose the good value for YOUR Xbox. 65 being the reference value). These points concern only SLIMS and XENON. They are useless for other revisions. Handle Double Nand (Ref to the last chapter) JTAG Port. Use pin header and our x360JtU to Flash your modchip through our 360gcProg Software. Timing Points.
Wires are provided with the chip. Use followings : 3.3v Use the 10cm lenght wire and adapt depending the chosen point. GND Use the AWG-22 Wire and adapt the length depending of the MB revision A Use the wire 4.5cm length for SLIM, and 10cm for FAT F Use the red wire 38cm for SLIM, 10cm for FAT D and E, Use wires of 5cm length C Use the 10cm length wire
WARNING : If your chip is NOT YET FLASHED, Refer to the manual How to flash your x360glitchip before continue.
3.3v sur U4E1 ou U4E2 ou R2F9 (The last one is the better one)
Use the same hole to get the twos wires on the top of the motherboard Use the 2 reds wires
Wire F of 38cm which finish the loop and goes to the chip
Wire F of 38cm coming from motherboard and goes make a loop of the ventirad
3.3 kOhm
10 Ohm
If you solder the I Pads, your glitched nand is on the INTERNAL nand If you solder the E, your glitched nand is on the EXTERNAL nand (On your Double Nand Addon)
We strongly recommands you to install the Glitched one on the INTERNAL nand and the Retail one on the EXTERNAL nand.