http://www.bentley.com/es-MX/Products/STAAD.Pro/Advanced+Analys...
Buscar
STAAD.Pro
Recursos
1. Advanced Solver
When performing an analysis with STAAD, there are several processes that are undertaken, including solving the stiffness matrix which can be the most significant time consuming part of the analysis process. The advanced solver is two solvers in one. This is because it can perform both in-core and out-of-core techniques. The out-of-core method creates and uses temporary data files, while the in-core method holds all the data stored within memory during the matrix formulation, which will be faster than out-of core if the temporary data files need to be written to disk. The advanced in-core solver is used for models with under 20,000 joints. The advanced out-of-core solver is used for models over 20,000 joints. The advanced in-core solver can be 500 to 2,000 times faster than the STAAD solver. The advanced in-core solver is between 100% and 200% as fast as the out-of-core solver method. The advanced analysis solver is particularly efficient for: Large models Models with large numbers of primary load cases Dynamic analysis Master/slave models Models requiring iterative solutions
Structural eSeminarsLearn more about our offerings by viewing our OnDemand eSeminars.
4. Pushover Analysis
1 dari 2
11/5/2012 11:59 PM
http://www.bentley.com/es-MX/Products/STAAD.Pro/Advanced+Analys...
Engineers can perform a pushover analysis as per FEMA 356 : 2000 and ATC 40. Pushover analysis is a static, non-linear procedure using a simplified non-linear technique to estimate seismic structural deformations. It is an incremental static analysis used to determine the force displacement relationship, or the capacity curve, for a structure or structural element. The analysis involves applying horizontal loads, in a prescribed pattern, to the structure incrementally; for example, pushing the structure and plotting the total applied shear force and associated lateral displacement at each increment until the structure is in a collapse condition. In the current implementation of the pushover analysis, the user can provide hinge properties as per table 5-6 and 5-7 of the FEMA 356 manual (Generalized Force-Deformation Relationship) and also enter the expected yield stress of steel. At present, the STAAD.Pro pushover analysis is only applicable to steel structures.
7. Base Isolators
One of the great new features in STAAD(X) is the ability to include base isolators at the base of columns to counteract the effects of vibration under the dynamic effects typically due to a seismic event such as an earthquake. STAAD supports low damping, high damping and lead rubber isolators. The analysis produces two sets of results, first with the isolator fixed (as though it were locked) and a second with the isolator free to deform as in its definition. One of the primary goals of a base isolator is to shift the fundamental period of the structure to a higher value and thus away from the peak accelerations which occur in lower frequencies. Once a base isolator which meets the required axial load and displacement demands has been determined, trial and error may be used to vary the fundamental period of the structure. Further, increased damping provided by base isolators can reduce the total seismic acceleration. Refer to Chapter 17 "Seismic Design Requirements for Seismically Isolated Structures" of ASCE 7-05 Minimum Design Loads for Buildings and Other Structures for additional information on the design of base isolators.
Blogs | Empleos | Privacidad | Condiciones de Uso | Contctenos | M apa del sitio web 2012 Bentley Systems, Incorporated
2 dari 2
11/5/2012 11:59 PM