Assignment in ce12
Arc welding
Arc welding is a type of welding that uses a welding power supply to create an electric arc between an electrode and the base material to melt the metals at the welding point. They can use either direct (DC) or alternating (AC) current, and consumable or non-consumable electrodes. The welding region is usually protected by some type of shielding gas, vapor, and/or slag.
Stick Welding Uses a consumable electrode (rod), with a flux coating. Stick welding requires a moderate to high skill level. Advantages: Portable Can be used in all environments Not as dependent on surface preparation
Mig Welding The electrode is a wire, fed from a spool to the end of the gun. A shielding gas is used to give atmospheric protection. This process requires a low to moderate skill level.
Advantages: 1) Very fast process 2) Easy to learn Disadvantages: 1) Weld area must be protected from air movements
Flux Core This process is a hybrid between Mig and Stick welding. It is the same process as Mig welding, except instead of a shielding gas, there is flux in welding wire. Advantages: 1) Can be done in all environments Disadvantages: 1) Requires additional clean up to remove flux
Tig Welding There is a Tungsten electrode through which the current is passed. (Melting pt. = 3700 degrees K) Argon is used as a shielding gas. Requires the highest skill level. Advantages: 1) Nearly all metals can be welded using this process. 2) Very precise Disadvantages: 1) Slow process
13. Clear all combustible materials from the welding area before welding. 14. Handle all compressed gas cylinders used in Mig and Tig welding with extreme care. Keep the cylinder caps in place when the cylinders are not in use. 15. When gas cylinders are empty, close the valve and mark cylinders empty. 16. When using water cooled equipment, check for water leakage often. 17. Use an audible signal such as cover to indicate to others that you plan to strike an arc. 18. If an electrode sticks, try to twist it free. If twisting fails to free the electrode, release the electrode from the electrode holder. Turn off the switch on the welder and use pliers to break the electrode free. 19. Avoid welding directly on concrete floors. Residual moisture in the concrete may be turned to steam resulting in the concrete exploding.