HUAWEI Confidential
In WCDMA signaling procedure, a complete access process contains following steps: RRC establishment Initial DT Authentication Security mode RAB assignment
HUAWEI Confidential
Page 2
Upon completion of this course, you will be able to: Describe the access counters Know access KPI
HUAWEI Confidential
Page 3
Chapter 1 RRC Establishment Counter and KPI Chapter 2 Security Mode Counter and KPI Chapter 3 RAB Assignment Counter and KPI Chapter 4 RB Counter and KPI
HUAWEI Confidential
Page 4
HUAWEI Confidential
Page 5
HUAWEI Confidential
Page 6
HUAWEI Confidential
Page 7
HUAWEI Confidential
Page 8
HUAWEI Confidential
Page 9
HUAWEI Confidential
Page 10
HUAWEI Confidential
Page 11
HUAWEI Confidential
Page 12
HUAWEI Confidential
Page 13
HUAWEI Confidential
Page 14
HUAWEI Confidential
Page 15
HUAWEI Confidential
Page 16
HUAWEI Confidential
Page 17
VS.RRC.Rej.AAL2.Fail
AAL2 setup failure
HUAWEI Confidential
Page 18
HUAWEI Confidential
Page 19
Measurement scope: RNC & Cell Description This KPI can be used to evaluate RRC setup success ratio about CS service, PS service and other reasons.
HUAWEI Confidential
Page 20
Counters (Cell)
RRCConnect ionAttempt cs : RRC.AttConnEstab.Cause RRCConnectionSuccesscs: RRC.SuccConnEstab.Cause
For example, the causes could be For RNC: OrgConv, OrgSubs, TrmConv, Rest, Emg, Unknown For Cell: OgConvCall, OrgSubCall, TmConvCall, CallReEst, EmgCall, Unkow
HUAWEI Confidential
Page 21
HUAWEI Confidential
Page 22
Counters (Cell)
RRCConnectionAttemptRATreselection : RRC.AttConnEstab.IRATCelRes RRCConnectionSuccessRATreselection : RRC.SuccConnEstab.IRATCelRes
HUAWEI Confidential
Page 23
HUAWEI Confidential
Page 24
Counters (Cell)
RRCConnectionAttemptregistration : RRC.AttConnEstab.Reg RRCConnectionSuccessregistration : RRC.SuccConnEstab.Reg
HUAWEI Confidential
Page 25
Chapter 1 RRC Establishment Counter and KPI Chapter 2 Security Mode Counter and KPI Chapter 3 RAB Assignment Counter and KPI Chapter4 RB Counter and KPI
HUAWEI Confidential
Page 26
This KPI can be used to evaluate security mode success rate in RNC
HUAWEI Confidential
Page 27
The measurement is triggered at point A as shown in the figure, that is, when RNC receives Security Mode Command from CN
SMCSuccess
VS.IU.Succ.SecMode The measurement is triggered at point B as shown in the figure, that is, when RNC sends Security Mode Complete to CN
HUAWEI Confidential
Page 28
Chapter 1 RRC Establishment Counter and KPI Chapter 2 Security Mode Counter and KPI Chapter 3 RAB Assignment Counter and KPI Chapter4 RB Counter and KPI
HUAWEI Confidential
Page 29
HUAWEI Confidential
Page 31
HUAWEI Confidential
Page 32
HUAWEI Confidential
Page 33
Notes: These counters can be used to evaluate the total CS RAB setup success rate
HUAWEI Confidential
Page 34
Notes: These counters can be used to evaluate different CS services RAB setup success rate.
HUAWEI Confidential
Page 35
Notes: These counters can be used to evaluate the total CS RAB setup success rate
HUAWEI Confidential
Page 36
Notes: These counters can be used to evaluate different CS services RAB setup success rate.
HUAWEI Confidential
Page 37
HUAWEI Confidential
Page 38
HUAWEI Confidential
Page 39
HUAWEI Confidential
Page 40
HUAWEI Confidential
Page 41
HUAWEI Confidential
Page 42
HUAWEI Confidential
Page 43
HUAWEI Confidential
Page 44
HUAWEI Confidential
Page 45
HUAWEI Confidential
Page 46
HUAWEI Confidential
Page 47
HUAWEI Confidential
Page 48
VS.RAB.FlEstPS.Str.RNL
VS.RAB.FailEstPS.RIPFail VS.RAB.FailEstPS.Par VS.RAB.FailEstPS.Relo VS.RAB.FailEstPS.Unsp VS.RAB.FlEstPS.Str.RNL.Other
VS.RAB.FailEstabPS.Other.Cell
HUAWEI Confidential
Page 49
HUAWEI Confidential
Page 50
Chapter 1 RRC Establishment Counter and KPI Chapter 2 Security Mode Counter and KPI Chapter 3 RAB Assignment Counter and KPI Chapter4 RB Counter and KPI
HUAWEI Confidential
Page 51
RB Counter System
RB setup counters (Cell)
Radio Bearer setup counters at point A:
VS.AttRBSetup
HUAWEI Confidential
Page 52
RB Counter System
RB setup failure counters (Cell)
Radio Bearer setup failure, due to:
Configuration unsupported: VS.FailRBSetup.CfgUnsup Physical channel failure: VS.FailRBSetup.PhyChFail Cell update occurred: VS.FailRBSetup.CellUpd Invalid configuration: VS.FailRBSetup.IncCfg No reply: VS.FailRBSetup.NoReply
HUAWEI Confidential
Page 53
RB Counter System
RB reconfigure counters (Cell)
Radio Bearer reconfiguration at point A:
VS.AttRBRecfg
HUAWEI Confidential
Page 54
RB Counter System
RB reconfigure failure counters (Cell)
Radio Bearer reconfiguration failure, due to: Configuration unsupported: VS.FailRBRecfg.CfgUnsup Physical channel failure: VS.FailRBRecfg.PhyChFail Cell update occurred: VS.FailRBRecfg.CellUpd Invalid configuration: VS.FailRBRecfg.IncCfg No reply: VS.FailRBRecfg.NoReply
HUAWEI Confidential
Page 55
Summary
Summary
This chapter mainly explained the KPIs about Accessibility RRC connection success rate RAB setup success rate Radio bearer counters
HUAWEI Confidential
Page 56
Thank you
www.huawei.com