Anda di halaman 1dari 2

its internal communication parameters accordingly.

It allows In Touch to be connected to any Digiplex control panel as well as any Spectra control panel V2.0 or higher. If connecting the APR-ADM2 to a Digiplex control panel, refer to the Digiplex APR-ADM2 Reference & Installation Manual.

PROGRAMMING METHOD
To access the In Touch programming mode: STEP 1: Press the [ENTER] key STEP 2: Enter your [INSTALLER CODE] STEP 3: Enter 3-digit section [SECTION] you wish to program. STEP 4: Enter the required data The module can also be programmed using the WinLoad Software. Refer to WinLoads Online Help for more information on programming with WinLoad.

INTRODUCTION
The Voice-Assisted Arm/Disarm Bus Module allows the user to arm or disarm their Spectra security system as well as activate or deactivate In Touchs PGM from any telephone. The APR-ADM2 uses detailed voice prompts to guide the user. Due to the Autopanel Recognition feature, the In Touch can be connected to either the Spectra (V2.0 or higher) or Digiplex control panels.

NUMBER

OF

RINGS

Section [575] The value (001 to 255, 000 = disabled) programmed in section [575] represents the number of rings the APR-ADM2 will wait before picking-up the line. If the line is not answered after the number of programmed rings, In Touch will answer the call. Be sure to program APR-ADM2s number of rings to be less than the number of rings programmed in the Spectra control panel or enter 000 as the number of rings for the Spectra.

TECHNICAL SPECIFICATIONS
Operating Voltage: Current Consumption: Power Consumption: PGM Outputs: Operating Temperature: Compatible Telephone: Compatibility: 9 - 15VDC Typical: 70mA Maximum: 105mA (with PGM enabled) 1 Watt 1 form C relay rated @ 125V, 5A receptive load 0C to 50C (32F to 122F) DTMF (Touch-tone) Any Spectra control panel V2.0 or higher

ANSWERING MACHINE OVERRIDE


Section [576] If In Touch uses a telephone line that uses an answering machine or service, the Answering Machine Override must be programmed. The value (010 to 255 seconds, 000 = disabled) programmed in section [576] represents the delay period that APR-ADM2 will wait between the first and second call. The user calls the In Touch, hangs-up, and then calls back within the value programmed in section [576]. If the APR-ADM2 is called back within the programmed delay period, the bus module will override the answering machine or service by picking-up the line on the first ring.

INSTALLATION
The APR-ADM2 is connected to Spectras communication bus. Connect the four terminals labeled 12VDC, GND, GRN, and YEL of the In Touch module to the corresponding terminals of the Spectra control panel as shown in Figure 1. Connect In Touchs RING terminal to Spectras R1 terminal and the TIP terminal of the APR-ADM2 to the T1 terminal of the Spectra control panel as shown in Figure 1. If the house-hold telephone is sharing the telephone line with Spectra and In Touch, connect the house-hold telephone to the R-1 and T-1 terminals of the APR-ADM2 as shown in Figure 1. Connect In Touchs PGM as shown in Figure 2. If the control panel is configured to report Arming and Disarming events and if the APR-ADM2 and control panel share the same telephone line, the users call will be interrupted during use.

PGM TIMER
Section [577] When the PGM is activated by a user, the value (001 to 255, 000 = No Timer) programmed in section [577] determines the time that APR-ADM2s PGM will remain activated. Once the time value set in section [577] has elapsed, the PGM will deactivate. If a value of 000 is entered into section [577], the PGM will remain activated until it is manually deactivated by the user. Option [4] in section [578] determines whether the PGM Timer programmed in section [577] is in seconds or minutes.

STAND-ALONE CODE LENGTH


Section [578] - option [1] This option determines whether the stand-alone code that the user enters to access the In Touch will be 4 digits in length or 6 digits in length. If section [578] option [1] is off, the stand-alone code will be

AUTO-PANEL RECOGNITION
This is a feature that allows In Touch to be used with either Spectra or Digiplex. When connected to the bus, the APR-ADM2 will automatically detect which system it is connected to and adjust

set to 6 digits in length. If section [578] option [1] is on, the standalone code will be set to 4 digits in length. If the stand-alone code is changed from 4 digits to 6 digits, In Touch will add the last two digits by using the first two digits. For example, if the access code is 1234 and you switch to six digits, the code will become 123412.

PGM TIME BASE SELECTION


Section [578] - option [4] This option determines whether the PGM Timer will be in seconds or minutes. If option [4] in section [578] is off, the PGM Timer will be in seconds. If option [4] in section [578] is on, the PGM Timer will be in minutes. Figure 2: Installing In Touchs PGM

PARTITION SYSTEM ON SPECTRA


Section [578] - option [2] If the Spectra control panel is partitioned, enable section [578] option [2]. If the Spectra control panel is not partitioned, disable section [578] option [2]. It is important that this is done correctly so that the APR-ADM2 module and the Spectra control panel can communicate properly.

PGM OUTPUT
Section [578] - option [3] If option [3] in section [578] is on, the APR-ADM2s PGM output is enabled and can be used. If option [3] in section [578] is off, In Touchs PGM output is disabled and cannot be used.

Figure 1: Installing the In Touch

Anda mungkin juga menyukai