SEAT BODY
SE
B140582E02
SE73
REMOVAL
1. 2. 3. 4. 5. REMOVE SHIFT LEVER KNOB SUB-ASSEMBLY (See page IP-14) REMOVE NO. 1 INSTRUMENT CLUSTER FINISH PANEL GARNISH (See page IP-14) REMOVE NO. 2 INSTRUMENT CLUSTER FINISH PANEL GARNISH (See page IP-14) REMOVE FLOOR SHIFT POSITION INDICATOR HOUSING SUB-ASSEMBLY (See page IP-15) REMOVE SEAT HEATER SWITCH (a) Disengage the 2 claws and remove the seat heater switch.
B140583E01
INSPECTION
1. INSPECT SEAT HEATER SWITCH (a) Inspect the driver side seat heater switch operation. (1) Measure the resistance according to the value(s) in the table below. Standard resistance
Tester Connection E55-6 (LH) - E55-5 (IG) E55-6 (LH) - E55-5 (IG) Switch Position OFF ON Specified Condition 10 k or higher Below 1
E55
If the result is not as specified, replace the switch. (2) Turn the seat heater switch on and check if the seat heater switch indicator comes on. OK
Measurement Condition Battery positive (+) Terminal E55-5 (IG) Battery negative (-) Terminal E55-4 (E) Specified Condition Comes on
SE
LH IG E
B126240E03
SE74
(b) Inspect the front passenger side seat heater switch operation. (1) Measure the resistance according to the value(s) in the table below. Standard resistance
Tester Connection E55-5 (IG) - E55-3 (RH) E55-5 (IG) - E55-3 (RH) Switch Position OFF ON Specified Condition 10 k or higher Below 1
E55
If the result is not as specified, replace the switch. (2) Turn the seat heater switch on and check if the seat heater switch indicator comes on. OK
Measurement Condition Specified Condition Comes on Battery positive (+) Terminal E55-5 (IG) Battery negative (-) Terminal E55-4 (E)
RH IG E
B126242E03
SE
E55
ILL+
ILL-
B126241E03
INSTALLATION
1. INSTALL SEAT HEATER SWITCH (a) Engage the 2 claws and install the seat heater switch. INSTALL FLOOR SHIFT POSITION INDICATOR HOUSING SUB-ASSEMBLY (See page IP-31) INSTALL NO. 2 INSTRUMENT CLUSTER FINISH PANEL GARNISH (See page IP-32)
2. 3.
B140583E01
SE75
4. 5.
INSTALL NO. 1 INSTRUMENT CLUSTER FINISH PANEL GARNISH (See page IP-32) INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY (See page IP-32)
SE