A-I
A-1
Annex A
I.
respective foreign Authorities, there will be added the letters KI. The ring, lines and letters are to be painted white or yellow on a dark ground, or else, black on a light ground. They shall be permanently attached on both sides of the ship. With ships having a restricted service range, depending on the respective range, the seasonal markings, such as for Winter North Atlantic trade, are omitted. Ships of over 100 m length do not get a WNA marking. For these ships WNA is equal to W and the LWNA marking is affixed at the same level as the W-mark. For ships the keels of which were laid prior to 21st July, 1968, the conditions for assignment of the freeboard subject to the Load Line Convention 1930 continue to be valid as a part of the ICLL. Where the advantages of the ICLL are intended to be utilized, the respective ships are to comply with all requirements of that Convention as for a new ship.
On application, Biro Klasifikasi Indonesia (BKI) calculate freeboards in accordance with the ICLL and with any existing relevant special national regulations, and subsequently issue the necessary Load Line Certificates wherever authorized to do so by the competent Authorities of the individual States. Applications for issuance of Load Line Certificates or for surveys of freeboard admeasurements are to be made to either BKI Head Office, Jakarta, or the Branch Office. Freeboards are then calculated and based on survey Reports and admeasurements Certificates are to be issued. The load lines assigned by BKI are marked amidships in accordance with the Freeboard Marking as per sketches on page A-2 which is drawn for the starboard side. Where no other marking is stipulated by National Regulations of the
A-2
Annex A
A - I
300 mm
115mm
75 mm
F
230 mm
25 mm
300 mm 450 mm
25 mm
T S W WNA
25 mm
230 mm 25 mm
300 mm
deck line
These measurement to be taken from centre of ring to top of each line 50 mm These measurement to be taken from centre of ring to top of each line assigned summer free board
540 mm aft
25
35 mm
540 mm forward
LT LS LW
115mm
LTF LF
230 mm
75 mm
TF
35 mm
25
F
230 mm
T S W WNA
230 mm 25 mm
25 mm
25 mm
LWNA
Upper edge of horizontal line passing through the centre of ring
300 mm 450 mm
25 mm
25 mm
230 mm 25 mm
*)
50 mm
TF