WINGS
(Workshop on AeroModelling & Aircraft Designing)
SKYCRAFT
(Workshop on Radio-Controlled plane Design & Flying)
WINGS
Session 2
o Getting your Hands Dirty o Construction of the 40cm Balsa Glider from the Pre-cut KIT o Flying the 40cm Balsa Glider o Experimenting with the different Wing Configurations & Learning
Session 3
An Introduction to Flight o What Makes Planes Fly? o Overview of Flight Control Surfaces o The Four Basic Forces of Flight o Basic Terminologies o How Planes can Maneuver
Session 4
An Introduction to Gliders o What are Gliders? How do they Glide? o Understanding the Wing and its Importance o Types of Wing Construction o Basic Glider Design - What goes where?
Session 5
o Design a Glider within given Constraints & Guidelines o Discuss the Designs
Session 6
o Cutting Techniques for Balsa o Cutting the Design from Balsa o Sanding & Smoothing Techniques o Sanding & Smoothing the Cut Balsa Designs- Putting it all together o Discuss concepts of Balance and Center of Gravity affecting Flight o Discuss techniques to Chuck o Flying the Gliders - Chuck & Catapult Launch
Session 7
Demonstration of RC Flying o Flying Demo of Basic Aerobatics, World War II Maneuvers, Pattern Flying & Stunt Flying
Practical Session
o Designing the individual part list as in figure - a. o Assembling the glider as shown in figure - b. o Giving the final touch as in figure - c.
Fee:
` 1200/- (inclusive of all Taxes) per participant including take away Balsa wood kit.
Prerequisites: None.
At the end of this module, the participant would be able to completely understand flight, stability and control.
Kit:
The following kit would be given to each team. Hardware:
Engine/ Electric Motor Electric Motor Controller Propeller Transmitter Receiver Li-Po battery Servo motors (2-4 pieces) Y connector Landing Gear ( tail wheel) Landing Gear (main) Wheels (3 pieces) Foam Styro Foam
Note: Kit will be provided in a team of 5 participants only. After hands on team will have to return kit. Fee:
` 1600/- (inclusive of all Taxes) per participant. No take Away Kit.
Process Guidelines
We want your association with us to make this workshop big success in your college. Date of conducting the workshop can be finalized by telephonic conversation with Coordinator/ Convener or Secretary, according to the College feasibility and slots available in our calendar. The entire workshop will be conducted at college campus. Each student participating in the workshop will get a participation certificate. Certificate of Merit for all the workshop participants from HoriZON (A Unit of MBS Group ). At the end of this workshop, a small competition will be organized among the participating students and winners will be awarded with a 'Certificate of Excellence'. Certificate of Coordination for the coordinators of the campus workshops.
Requirements
Accommodation Facility for Team Members. Seminar Hall and Open College Ground having a capacity enough to conduct hands-onsession for all participants. Good Quality public address system ideally two cordless mikes will be required. Projector/ Screen along with black/white board for teaching and presentation purposes. One small stereo jack cord to connect in laptop for its sound system. Internet Connectivity in the seminar hall/classroom (If Possible) The workshop canter can only be arranged for a minimum of 100 students.
Contact
We ensure that you will find our training programs extremely beneficial for students. If you have any queries kindly get back to us. We are looking forward to a quick and positive response from you and a long term association with your esteemed organization. Regards
Sumit Choubey Business Manager| MBS GROUP Mobile: +91-98235-48095 Email ID: sumit@mbsgroup.in Website: www.mbsgroup.in
MBS Group Provoking Thoughts, Multiple Business Solution provider @ One Place