LED-75W-M Series
Dimmable LED Drivers Constant Current & Constant Voltage Aluminum Housing
Electrical Specifications
Input Voltage Range: Frequency: Power Factor: Inrush Current: Input AC Current: Maximum Power: Line Regulation: Load Regulation: Leakage Current: Turn-on Delay: Ripple and Noise: Protection: 100-277 VAC Nom. (90-305 Min/Max) 50/60 Hz >0.90 @ full load, 100V through 277V 50.0 Amps max @ 220 VAC, cold start 25C 0.9 A max @ 110VAC, 0.42 A max @ 220VAC 75W 1% 3% Constant Current, 2% Constant Voltage 1 mA 277VAC 50Hz 3S @ 110VAC, 1.5S @ 220VAC 5% Vo Over-Temperature, Over-Voltage (Latch Mode), Over-Current, and Short Circuit Protection
Environmental Specifications
Operating Temperature: Maximum Case Temp. Storage Temperature: Humidity: Cooling: MTBF: Lifetime: EMC: Weight: -35C to +70C 90C -40C to +85C 5% to 100% Convection 300,000 Hours 50,000 Hours FCC 47CFR Part 15 Class B compliant 1.87 lbs. (0.85 kg)
E332160
Note: LED drivers are designed and intended to operate LED loads only. Non-LED loading may be outside the specified design limits of our LED driver, and therefore cannot covered by any warranty. If you desire to use our LED drivers to operate non-LED loads please contact us to discuss compatibility. Specifications subject to change without notice.
LED75W-081-M LED75W-105-M
5-21-13
Thomas Research Products 11548 Smith Dr. Huntley, IL 60142 T: 847-515-3057 F: 847-515-3047 www.trpssl.com
Minimum
9.8V 0 mA -2v 0mA 19.8K
Typical
10V 20K
Maximum
10.2V 10mA 12v 0.5mA 20.2K
10V (YELLOW)
LED75W-xxx-Cxxxx-M-D
Vdim (V)
10
Notes:
1. If dimming is not required, connect the yellow and purple leads together to get full light output (100%). 2. Io is actual output current and Ir is rated current. 3. For the driver to operate properly,the load voltage must be maintained above the minimum voltage threshold (approx.60% of the max.output voltage for any given model). 4. If the output voltage is maintained above 50 of the maximum output voltage ,the dimming control may be operated over the entire 110V range with output current varying from 100 down to practically 10. 5. The dimming input signal may be less than 1V; however, no further dimming will occur between 0V and 1V. Derating Curve
100 80 100 80
Derating Curve
Load (%)
60 40 20 0 -20
Load (%)
-10 0 10 20 30 40 50 60 70
60 40 20 0
90
120
150
180
210
240
270
300
330
Thomas Research Products 11548 Smith Dr. Huntley, IL 60142 T: 847-515-3057 F: 847-515-3047 www.trpssl.com
Dimensions - mm
1) Constant Current, Fixed Output
AC INPUT (3*AWG18)
White (ACN) Black (ACL) Green (GND)
DC OUTPUT (2*AWG18)
Red (+) Black (-)
DC OUTPUT (2*AWG18)
Red (+) Black (-)
Thomas Research Products 11548 Smith Dr. Huntley, IL 60142 T: 847-515-3057 F: 847-515-3047 www.trpssl.com
Dimensions - mm
3) Constant Voltage
AC INPUT (3*AWG18)
White (ACN) Black (ACL) Green (GND)
1771.0 1731.0
DC OUTPUT (2*AWG18)
Red (+) Black (-)
50 0.5 34 0.5 4 4
10.5
Tc=90C
37
65020 505
22020
371.0 505
102
Thomas Research Products 11548 Smith Dr. Huntley, IL 60142 T: 847-515-3057 F: 847-515-3047 www.trpssl.com
102
67.5 1.0