Anda di halaman 1dari 7

New Features in

General

Parts can be organized into folders to make it easier to turn on or off many parts together.

Sections can be organized into folders to make it easier to turn on or off many sections together.

Group definition of sections segments. Section segment definition allows drawing of more than one section segment. These segments will be autonumbered and placed into a folder having the name of the segment.

Textures can be assigned to materials.

Texturized view.

Report Manager can handle scaling and rotation of drawings. Rotation and scaling are also supported when printing individual drawings from the program.

Importing model framework and load definition from IFC files. Az IFC 2x3-as formtumtl kezdden lehetsg van statikai vzak kzvetlen tadsra is IFC fjlok segtsgvel. Ezt a betltsi mdot csak akkor vlaszthatjuk, ha az IFC llomnyban ezek az adatok (csompontok, valamint a statikai vzat ler topolgia, tmaszok, terhek, teherkombincik) tnylegesen szerepelnek is. AxisVM Tekla Structures (Xsteel) integrated data exchange module. Tekla Structures can use AxisVM as an analysis engine. Tekla Structures can run AxisVM, transfer the model including structural elements, supports, loads and load combinations. After running the analysis all results can be displayed and design calculations can be made. (optional TI module)

Elements
Direct drawing of structural objects. Direct drawing of walls, slabs, holes, beams and columns with full control of the parameters (material, cross-section, height, thickness, etc.).

Diaphragm elements Diaphragms can be used to model plates rigid within their planes to considerably speed up overall stiffness calculation and seismic analysis.

Multiple core processor support (meshing, calculating critical combinations, reinforcement, etc.). (optional MT module)

Loads
Moving loads on beams and surface elements.

Distribution of surface loads over trusses as nodal forces.

Post tensioning of beams and ribs. Calculating losses, equivalent loads, displacement and forces of post tensioned elements with 3D cable geometry. Tabular and graphic output of cable trajectories. (optional PS module)

Analysis
Maximum size of the system of equations: 32 GB . The new solver is twice as fast as 8(+). Multithreading to make the best of multiple core processors.

Vibration analysis Optional replacement of plates with diaphragms to speed up the calculation

Results
Extended Critical Combination generation. If more than one permanent load group is defined load combination can contain load cases from one group with the upper safety factor while load cases from the other group are calculated with the lower safety factor.

Design
N-M-V and N-M-buckling analysis of compressed beams with any cross-section.

March, 2008.

Anda mungkin juga menyukai