Update by USB
RX-V473
1 Power off the receiver (Standby mode) 2 Enter the ADVANCED SETUP mode
While pressing the STRAIGHT key, press the (Power) key and keep STRAIGHT key pressed until A D V A N C E D S E T U P appears on the front panel display.
UPDATE.....USB
UPDATE.NETWORK
* If U P D A T E S U C C E S S appears, this means your receiver is already up-to-date. In this case, power off to
exit from Advanced Setup. Your AV receiver is ready for normal use. Firmware update in progress
NETWORK UPDATE
VERIFYING...
Sx-x:xx%
Caution
DO NOT interrupt power during the update. In case the power is accidentally cut off resulting in a condition where you cant recover normal operation, refer to the troubleshooting method (Troubleshooting CASE 2) on the last page. b. When completed, U P D A T E S U C C E S S appears on the display.
UPDATE SUCCESS c. Turn off the power of the receiver by pressing the
INFO key (Power) key PROGRAM key
(Power) key.
STRAIGHT key
RX-V473
rmware version
a. Power on the AV receiver and press the b. Select Network > Network Update. c. Con rm that the rmware version is updated to the latest version.
SETUP key
Congratulations!
You have completed the rmware update. Your AV receiver is ready for normal use.
RX-V473
2 Power off the receiver (Standby mode) 3 Insert the USB thumb drive
USB port is located at the lower left corner of the front panel.
ADVANCED SETUP
RX-V473
rmware update
a. Press INFO key to start the update. (Update process may take up to 10 minutes)
* If U P D A T E S U C C E S S appears, this means your receiver is already up-to-date. In this case, power o to
exit from Advanced Setup. Your AV receiver is ready for normal use. Firmware update in progress USB UPDATE VERIFYING... Sx-x:xx%
Caution
DO NOT interrupt power during the update. In case the power is accidentally cut o resulting in a condition where you cant recover normal operation, refer to the troubleshooting method ( Troubleshooting CASE 2 ) on the last page. b. When completed, U P D A T E S U C C E S S appears on the display.
(Power) key.
rmware version
a. Power on the AV receiver and press the b. Select Network > Network Update. c. Con rm that the rmware version is updated to the latest version.
SETUP key
Congratulations!
You have completed the rmware update. Your AV receiver is ready for normal use.
RX-V473
USB UPDATE
UPDATE SUCCESS
DIRECT key
USB port