Cola®Lube 3410
Page 1 of 3
Colonial Chemical, Inc. Emergency Telephone #
225 Colonial Drive 423/837-8800
S.Pittsburg, TN 37380 Chemtrec 800/424-9300
SECTION I – PRODUCT INFORMATION
Product Name: Cola®Lube 3410 File: 3410
C.A.S. No.: PROPRIETARY
Health Hazard Rating: Health – 1 Flammability – 1 Reactivity – 0
Effects of Overexposure:
Eyes – Concentrate may cause eye irritation. Recommended use dilutions (10%
or less) are not expected to cause eye irritation.
Skin – Concentrate may cause skin irritation. Recommended use dilutions are
not expected to cause skin irritation.
Skin Absorption – Concentrate is not expected to be toxic. LD50 (rabbit) is > 2 g/kg
Ingestion – Concentrate is not expected to be toxic. LD50 (rat) is > 5.0 g/kg.
Inhalation – TLV for product not established.
Chronic Effects – A review of the literature does not show obvious long-term hazard.
Carcinogenicity – Product not listed as a carcinogen with OSHA, NTP and IARC.
First Aid:
Eye Contact – Immediately flush with copious amounts of water for at least 15
minutes. Consult physician
Skin Contact – Immediately flush with copious amounts of soap and water for at
least 5 minutes. Remove contaminated clothing. If irritation persists,
contact physician. Launder contaminated clothing before reuse.
Ingestion – Contact poison control center or physician immediately. Do
not induce vomiting or give anything by mouth to an unconscious
person.
Inhalation – Remove to fresh air. Consult physician.
SECTION VII – SPECIAL PROTECTION INFORMATION
Respiratory Protection: Not required unless excessive dust or misting occurs, use NIOSH
approved respiratory protection.
Ventilation: Normal for chemicals of this nature.
Eye Protection: Chemical goggles or full-face shield
Protective Gloves: Impervious type
Other Protection: Wear protective clothing to prevent skin contact
SECTION VIII – SPECIAL PRECAUTIONS
Precautions To Be Taken In Handling And Storing: Keep container closed when not in use.
Avoid contact with eyes, skin, and clothing. Avoid breathing mists. Wash thoroughly after
handling. Bring product to room temperature before using.
Steps To Be Taken In Case Of Spill Or Release: DO NOT USE WATER! Absorb with inert
material (dry sand, earth, etc.), then place chemical waste in container. For large spills, dike for
later disposal.
HEALTH 1
FLAMMABILITY 1
REACTIVITY 0
PERSONAL PROTECTION B
The above data is for information purposes only and is accurate to the best of Colonial Chemical,
Inc.’s knowledge. No guarantees or liabilities are expressed or implied.
REVISED: 12-14-2007/J.STAFFORD