Y2006/Y2007
www.realknots.com
Program outline Knot Scout sign-up form Knot instructions and use. Bibliography, Resources Knot games
Compiled by BSA Troop 2, Tolland, CT. 1
K n o t co u n se l o r (P rin t)
C o u n se l o r si g n a tu re
Important information
This program is recommended for scouts of 1st class or higher rank but is open to anyone in the troop Knots may be listed and completed in any order Practice is key: Counselor coaching and test/signoff must occur in 2 separate sessions Scout must KNOW how to tie the knot and what it is used for When 10 knots are signed off, return this form to the current knot program coordinator Completion of 10 knots entitles the scout to the prize listed in the program guide No repeats Work on subsequent sets of 10 may not repeat any knots. See overleaf for the basic knot elements
Knot List
1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21. 22. 23. 24. 25. 26. Alpine Butterfly (Butterfly knot) Ashleys stopper knot Barrel knot Bimini Twist Boa knot Boatswains Weave Bowline on a bight Block and tackle Blood loop (FMB) Chain Sennit* Cleat wind Constrictor knot Clinch knot / improved clinch knot (FMB) Dropper knot Duncan loop (or Uni knot) Eye splice Figure eight knot Fishermans knot Flemish bend Four in hand knot Gasket coil Heaving Line Knot Monkeys fist Mooring hitch Palomar knot(FMB) Perfection loop
27. 28. 29. 30. 31. 32. 33. 34. 35. 36. 37. 38. 39. 40. 41. 42. 43. 44. 45. 46. 47. 48. 49. 50.
More coming..
Pineapple knot Pratt knot Prusik Knot Sailors hitch (Gripping) Sailors hitch Round crown sennit* Sheepshank Snelling a hook Square Chain Sennit* Square Crown Sennit* Square knot sennit Stevedores knot (Overhand)Stopper knot Surgeons knot Surgeons loop(FMB) Swiss seat Timber hitch Trick Sennit Trilene knot Truckers hitch Turks head knot * : No instruction page yet, Turle knot (FMB) see reference material Water knot Zeppelin bend (FMB): Fishing merit badge requirement
Knot: A method for fastening or securing linear material such as rope by tying or interweaving. Getting to know the elements of a knot will make it easier to learn most knots. The following pages contain uses and instructions on some of the many knots.
Compiled by BSA Troop 2, Tolland, CT.
Used to make a loop in the middle of a rope. The rope still runs straight and so will be under less stress than if a figure eight knot were used for the same purpose.
See animation on www.grogono.com/knot or http://www.geocities.com/roo_two/butterflyloop.html
Compiled by BSA Troop 2, Tolland, CT. 6
Troop 2 Knot Program Knot instruction/Use Barrel knot (Or Blood Knot)
1. 2. Cross both pieces in and x leaving at least 8 overlap Wind one end around the standing part of the other 5 times and pass the end on the other side of the X formed by the intersection Pinch the line at this point and with the other hand wind the free end around the standing part in the other direction 5 times. Pass this end through the same loop as the first end but in the opposite direction Lubricate and hold (dont pull)both ends while pulling on the standing parts to tighten. This knot is used to tie 2 lines together, especially in fishing applications
Compiled by BSA Troop 2, Tolland, CT. 8
3.
4.
From Ron Brooks, Long, non-slip double lines are a necessity when trolling for big billfish. Short versions are helpful and easy to tie.Difficulty: AverageTime Required: 3 minutes Here's How: 1. Take about 4 yards of line from the reel, and sit down on a chair. 2. Run the line under your shoes and up to your thighs. Take the tag end in one hand and the rod end in the other. You should feel like you are about to tie your legs and feet together. 3. Hold both pieces of line in front of you and above your lap. 4. With your knees together, twist the tag end of the line around the rod end about 10 or 12 times. You should now have a loop of line that goes under your shoes and is around both of your thighs, and closes at the twists above your lap. 5. Take the tag end of the line in one hand, the rod end in the other, and simultaneously begin moving your knees apart as you move your arms apart. This will shorten and tighten the twists in the line in front of you. 6. Continue this until the twists are extremely tight. 7. Now begin to relax the tension on the hand that has the tag end. As you do so, continue the tension with your other arm and knees. Move the arm with the tag end down as the tension is released, The line will double back on itself and twist the other direction and down over the previous twists. 8. Continue tension and tie two half hitches around one of the single lines at the bottom of the twist. 9. Finish with two half hitches at the bottom of the twist around both lines. Tips: 1. The length of the double line can be adjusted by adjusting the distance between your feet. 2. Very long double lines can be tied with this method by using some innovation. Try placing the loop end of the line around a stationary object and then under your feet. The tension can still be acquired by spreading your knees.
Same as the constrictor knot but with an additional coil in the beginning and slightly more ornamental when finished. Quick to tie, bonds strongly. Both can also be tied to a pole with the rope end rather than with the bight, much like the clove hitch. Compiled by BSA Troop 2, Tolland, CT.
10
11
Like the French bowline the bowline on a bight forms two loops, but they must be of the same size. Start by making a good size bight and an overhand loop. Bring the end loop down and around the entire knot. Set the knot securely before putting weight on it.
See animation on www.grogono.com/knot
12
14
15
Quick to tie, bonds strongly. For a quick whipping of a fraying ropes end or for tying the neck of a sack or bag
Compiled by BSA Troop 2, Tolland, CT.
16
Troop 2 Knot Program Knot instruction/Use Clinch knot (And Improved Clinch knot)
The usual way to tie a fly to the end of a tippet. 1- Insert 6-8 of line through the eye of the hook 2- hold the fly in the left hand and with the right hand coil the line around the standing part 5 times keeping a small loop close to the hook eye. 3- Bring the tag or running end of the line back through the hook eye and grasp with the left thumb and forefinger. 4- Lubricate and tighten by gently pulling the standing part and the tie, do not pull the tag end of the line. Trim the tag end closely. The Improved Clinch knot is achieved by passing the tag end back through the loop caused in step 3. However, experiment with this before judging between the two methods. 17
Compiled by BSA Troop 2, Tolland, CT.
18
19
Makes a strong eye on the end of a rope. Shown above is 4 complete tucks For todays more slippery materials a minimum of 5 complete tucks is necessary. For long term or critical applications a minimum of 7 is necessary. See animation on animatedknots.com
Compiled by BSA Troop 2, Tolland, CT. 20
Used as a stopper knot to ensure a knot end will Not slip through. It is also used to start some other knots such as the figure eight bend
21
The fishermans knot is used for joining two fine lines such as fishing leaders. It is simply two overhand knots, one holding the right-hand line and the other the left-hand line. Pull each of the two overhand knots taut separately. Then make the whole knot taut so the two overhand knots come together by pulling on the standing parts of each line.
22
6 5 7
For safety, the tail ends should be longer than pictured and can then be tied in a doube overhand stopper knot as shown below.
23
For tying your neck tie under a medium collar also look into the windsor and half windsor knots for wide and medium collars respectively.
Compiled by BSA Troop 2, Tolland, CT. 24
A method for neatly storing your length of rope or to gather up excess and keep it out of the way..
25
26
(Page 1 of 4)
The Monkeys fist is used on the end of a line to make it easier to catch. 1. Begin with 3 three loose parallel loops around the Spread fingers of your left hand. Leave about 18 Hanging at the beginning. We call this set of loops A loops 2. Start a fourth loop only this time come between Your little and ring fingers
Compiled by BSA Troop 2, Tolland, CT. 27
(Page 2 of 4)
3. Now work the end of the line back between your little and ring fingers close to your palm to capture the A loops. Also keep these loops loose. 4. Next, pass the line over, between your ring and middle fingers and come back through these same fingers. 5. Repeat this process going through your middle and Index fingers. Well call these the B loops
Compiled by BSA Troop 2, Tolland, CT. 28
(Page 3 of 4)
7
We are know looking down on your finger tips. 6. Bring a second loop down between your middle and index finger, only this time pass the line down the back side of your index finger inside the A loops 7. Next bring the line back up (hand to fingertip) along the back side of your little finger going inside of the A loops. You should begin to be capturing the B loops. These are the C loops 8. Now come over the top and run the line down the top of your index finger. Again capturing B loops but staying inside of the A loops
Compiled by BSA Troop 2, Tolland, CT. 29
(Page 4 of 4)
9. Repeat number 7 only going down the palm side of the little finger. At this point you should be able to pull your fingers out and with a little tightening begin to form a ball. 10. Now make a 3rd C loop, paralleling the 2nd. 11. Start a 4th loop going back down parallel to the 4th loop. This finishes the knot tying part. 12. Insert your weighted core and start working the loops to tighten the knot. 13. Finishing can be done with any seizing technique such as a clove hitch.
See animation on http://131.230.57.1/knots/m_fist.htm Compiled by BSA Troop 2, Tolland, CT.
30
31
32
34
The Pineapple Knot falls within the general group of knots known as turksheads. What is unusual about it is that it is actually 2 interwoven turksheads, the first one most often being a 7 part, 6 bight knot, and then the 2nd, with 5 parts, and 6 bights, being tied within the structure of the first. Unlike some other turksheads, the Pineapple Knot is well suited to being tightened down over a generally spherical object, and with care, will close down to the point where it will almost entirely cover such a shape. It is a knot much used by leather braiders, but is less widely known among ropeworkers
Compiled by BSA Troop 2, Tolland, CT. 35
36
37
38
39
A knot tied in the bight for shortening a rope or taking up slack, without cutting it. It can also be used to protect a weak, damaged or frayed section of the rope.
40
Try th is
challe ng e
41
42
Like the Figure 8 knot this is a stopper knot and is used to provide extra holding power to knots and hitches.
Compiled by BSA Troop 2, Tolland, CT. 44
This is one of the most basic knots. Even a small child can do this intuitively. The knot itself is small, and hard to untie after heavy load. The untieing is greatly simplified leaving a drawloop (right drawing). This also makes the knot slightly bulkier and perhaps a little stronger. Do notice, that an overhand knot reduces the breaking strength of a rope by as much as 50%! So do not tie an overhand knot unnecessarily in the middle of a rope.
45
46
47
Used as a rappelling or rescue harness. Starts with even lengths of a long rope and the first part of a surgeons knot (2 half a square knots) Finishes on the left hip with a square knot and 2 half hitches on each side of the square knot.
Compiled by BSA Troop 2, Tolland, CT. 48
50
A strong and reliable knot to secure monofiliment to hooks, swivels & lures. Resists slippage and failures.
51
Used to pull and hold a rope tight to hold cargo down on a car top or trailer Tie off one end of the rope. Tie a slippery half-hitch in the middle of the rope to form a loop. With the free end make a turn around a fitting and bring it the free end back to the loop. Feed through and pull the line tight Finish off with 2 half hitches.
52
53
54
55
56
57
Instructional: 20 minutes
1.Knot review and maybe a couple new ones. To win games later, pay attention now. Each scout with a 2ft piece of cord > Turn it in at the end! Leader shows knots and scouts follow along with their cord Follow knot list below
Knot list: 1. Overhand knot.2. Figure eight knot. 4. Sheet bend 5. Bowline 7. Taught line hitch 8. Fishermans knot. 3. Reef knot (square knot) 6. Turn & 2 half hitches 9. Sheepshank
58
Games: 40 minutes
Knot Relay ~20 min The game simply involves each member of the team running across the field of say, 20 feet wide, where they are told a knot to tie, and they must tie that before returning to their team and the next person running up to do their knot. Each player will be given a knot in a predetermined sequence and the sequence will be the same for all teams. Therefore the Scouts know that if they do not pay attention during the learning phase of the evening they will let their team down during the game phase. This is often sufficient incentive for them to make every effort to learn. You will need to decide in advance how to handle a competitor who, after making several attempts, still fails to tie the required knot, one possibility is for the next person in the team to come up (after the previous has been there for a set period of time), then the next person must tie the knot that the previous person failed at and one more person must come up at the end of the race so that the required number of knots get tied. Use #s 1 through 8 in the knot list above. WDS: As suggested above - Maximum time per scout: 1 minute. Then the next in line must pick up from the untied knot. All knots must be tied by each team. Winning team is that which completes all knots properly first, then 2nd, 3rd, etc.
59
60
Bibliography, Resources
Knots and how to tie them BSA pub 33170 www.realknots.com www.troop7.org/knots www.une.edu.au/~unemc/alpbutt.htm www.marinews.com www.killroys.com/knots www.fishing.sh/index.html www.geocities.com/roo_two/knotindex.html www.grogono.com/knot www.answers.com www.animatedknots.com http://www.tie-a-tie.net/pratt.html http://wikipidia.org http://knotical-arts.com http:Neropes.com/splice The Ashley book of knots http://snakewhip.com/pineappleknot/pa.php http://www.kismeta.com/diGrasse/button_knots.htm The Morrow guide to knots, M. Bigon & G. Regazzoni Knotcraft, Allan and Paulette Macfarlan Handbook of knots, expanded edition; Des Pawson For those that are nuts about mathematical knot theory; http://library.thinkquest.org/12295/main.html
Compiled by BSA Troop 2, Tolland, CT. 61
Notes: 1- Consider troop2 knotboard for recruiting day 2- Count candidates, buy 6 X 2 colors rope 3- Knot program briefcase or duffle Ideas for future -Build in basic knot review for rusty scouts. Hold the mastery of these to a higher standard than fancy knots. Scouts should really know these well -Add knot detective (knotcraft p148) and other games -Plan & suggest campout with knot theme -Plan for next year a troop meeting focused on knot learning and fun. Aim for Sept/Oct?
62