Notes
Type
Volumetric Troffer
2VTLED
2' x 4' LED
INDUSTRY RECOGNITION/AWARDS
Lead times will vary depending on options selected. Consult with your sales representative. ADP Diffuser ADP Acrylic linear prismatic Voltage (blank) MVOLT 347 3472 Wattage D24 D40 D47 D75 24W 40W3, 5 47W3, 6 75W3, 7
3,4
Color temperature LP835 82CRI, 3500K LP840 82CRI, 4000K LP850 82CRI, 5000K8
Controls NX BLD N80 Dimming, no nlight Bi-level dimming nlight with 80% lumen management. N80EMG nlight with 80% lumen management. For use with generator supply EM power. N100 nlight without lumen management. N100EMG nlight without lumen management. For use with generator supply EM power.
nLight Control Accessories: Order as separate catalog number. Visit www.sensorswitch.com/nLight for complete listing of nLight controls. WallPod stations On/Off On/Off & Raise/Lower Graphic Touchscreen Photocell controls Continuous dimming On/Off & Dimming Model number nPODM [color] nPODM DX [color] nPOD GFX Model number nCM ADC nCM PC ADC Occupancy sensors Standard range 360, ceiling (PIR / dual tech) Extended range 360, ceiling (PIR / dual tech) Wide view (PIR / dual tech) Cat-5 cable bundles (plenum rated) 10', CAT5 10FT 15', CAT5 15FT Model number nCM 9 / nCM PDT 9 nCM 10 / nCM PDT 10 nWV 16 / nWV PDT 16 Model number CAT5 10FT J1 CAT5 15FT J1
Accessories: Order as separate catalog number. 2VT4 F916 DGA24 Trim to adjust fixture mounting flush with 9/16" T-bar; for 2x4 fixture Drywall ceiling adaptor , unit installation
4 5 6 7 8 For use with 24L. For use with 40L. For use with 48L. For use with 72L. Not available with 4000 lumen system.
Notes 1 Approximate lumen output. 2 Consult factory for availability. Not available with EL14 battery pack or BLD controls. 3 Approximate input power (watts) +/-5%.
LED
2VTLED-2X4
60
CP Summary 0 90 0 1424 1424 5 1412 1419 15 1341 1366 25 1212 1272 35 1029 1138 981 45 818 800 55 596 612 65 383 390 75 192 112 85 43 2 2 90
Coefficients of Utilization pf 20% pc 80% 70% 50% pw 70%50%30% 50%30%10% 50%30%10% 0 119 119 119 116 116 116 111 111 111 1 108 103 99 101 97 93 97 93 90 2 98 90 83 88 81 76 84 79 74 3 89 79 70 77 69 63 74 67 62 4 82 70 61 68 60 53 66 58 53 5 75 62 53 61 52 46 59 51 46 6 69 56 47 55 46 40 53 46 40 7 64 51 42 50 42 36 48 41 35 8 60 46 38 46 37 32 44 37 32 9 56 43 34 42 34 29 41 34 28 10 53 39 31 39 31 26 38 31 26
2VTL4 48L ADP LP835, 4740 delivered lumens, test no. LTL20367, tested in accordance to IESNA LM-79
180 90 80 300 600 900 1200 1500 0 0 20 90 40 60
CP Summary 0 90 0 1678 1678 5 1662 1671 15 1580 1612 25 1425 1499 35 1207 1346 45 950 1159 949 55 682 725 65 434 478 75 215 143 85 48 5 2 90
RCR
Zonal Lumen Summary Zone Lumens % Lamp % Fixture 0 - 30 1090 27.1 27.1 0 - 40 1772 44.0 44.0 0 - 60 3103 77.1 77.1 0 - 90 4027 100.0 100.0 90 - 180 0 0.0 0.0 0 - 180 4027 100.0 100.0
Coefficients of Utilization pf 20% pc 80% 70% 50% pw 70%50%30% 50%30%10% 50%30%10% 0 119 119 119 116 116 116 111 111 111 1 108 103 99 101 97 93 97 93 90 2 98 90 83 88 81 76 84 79 74 3 89 79 70 77 69 63 74 67 62 4 82 70 61 68 60 53 66 58 53 5 75 62 53 61 52 46 59 51 45 6 69 56 47 55 46 40 53 46 40 7 64 51 42 50 41 36 48 41 35 8 60 46 38 46 37 32 44 37 32 9 56 43 34 42 34 29 41 33 28 10 53 39 31 39 31 26 38 31 26
RCR
Zonal Lumen Summary Zone Lumens % Lamp % Fixture 0 - 30 1284 27.1 27.1 0 - 40 2086 44.0 44.0 0 - 60 3649 76.9 76.9 0 - 90 4742 100.0 100.0 90 - 180 0 0.0 0.0 0 - 180 4742 100.0 100.0
Efficiency: 100.0%
Mounting data
9/16
15/16
Dimensions
All dimensions are inches (centimeters) unless otherwise specified.
SS
POWER INPUT
LIGHT OUTPUT LIGHT OUTPUT POWER INPUT
Saved Energy
POWER INPUT
POWER INPUT
LIGHT OUTPUT
Wasted Energy
LIGHT OUTPUT
80% 0 10 20 THOUSAND OPERATING HOURS 30 40 38W 50 80% 0 10 20 THOUSAND OPERATING HOURS 30 40 38W 50
Notes 1 With nlight 80% lumen management input watts start at 38 and gradually increasing to 47 at 50,000 hrs when using 48L system.
2VTLED-2X4
LED:
Phone: 800-858-7763
Fax: 770-929-8789
www.lithonia.com
Rev. 09/10/12
Type
Volumetric Troffer
2VTLED
2' x 2' LED
INDUSTRY RECOGNITION/AWARDS
WARRANTY 5-year limited warranty. Complete warranty terms located at www.acuitybrands.com/CustomerResources/Terms_and_conditions.aspx Note: Specifications subject to change without notice.
Lead times will vary depending on options selected. Consult with your sales representative. ADP Diffuser Voltage (blank) MVOLT 347 3472 Wattage D24 24W
3
Color temperature LP835 82 CRI, 3500K LP840 82 CRI, 4000K LP850 82 CRI, 5000K
Controls NX BLD N80 N80EMG Dimming, no nlight Bi-level dimming nlight with 80% lumen management. nlight with 80% lumen management. For use with generator supply EM power. N100 nlight without lumen management. N100EMG nlight without lumen management. For use with generator supply EM power.
24L 2400 ADP Acrylic lumens1 linear prismatic 36L 3600 lumens1
D36 36W4
nLight Control Accessories: Order as separate catalog number. Visit www.sensorswitch.com/nLight for complete listing of nLight controls. WallPod stations On/Off On/Off & Raise/Lower Graphic Touchscreen Photocell controls Continuous dimming On/Off & Dimming Model number nPODM [color] nPODM DX [color] nPOD GFX Model number nCM ADC nCM PC ADC Occupancy sensors Standard range 360, ceiling (PIR / dual tech) Extended range 360, ceiling (PIR / dual tech) Wide view (PIR / dual tech) Cat-5 cable bundles (plenum rated) 10', CAT5 10FT 15', CAT5 15FT Model number nCM 9 / nCM PDT 9 nCM 10 / nCM PDT 10 nWV 16 / nWV PDT 16 Model number CAT5 10FT J1 CAT5 15FT J1
Accessories: Order as separate catalog number. 2VT2 F916 DGA22 Trim to adjust fixture mounting flush with 9/16" T-bar; for 2x2 fixture Drywall ceiling adaptor , unit installation
Notes 1 Approximate lumen output. 2 Consult factory for availability. Not available with EL14 battery pack or BLD controls. 3 For use with 2400 lumen system. Approximate input power (watts) +/-5%. 4 For use with 3600 lumen system. Approximate input power (watts) +/-5%.
LED
2VTLED-2X2
2VTL2 24L ADP LP835, 2425 delivered lumens, test no. LTL20369, tested in accordance to IESNA LM-79
90 100 200 300 400 500 600 700 800 900 0 0 180 20 90 40 60 80
CP Summary 0 90 0 943 943 5 931 941 15 870 902 25 755 829 35 607 731 45 461 616 55 329 494 65 210 373 75 104 235 85 23 53 90 1 1
Coefficients of Utilization pf 20% pc 80% 70% 50% pw 70%50%30% 50%30%10% 50%30%10% 0 119 119 119 116 116 116 111 111 111 1 109 104 100 102 98 94 97 94 91 2 99 91 84 89 82 77 85 80 75 3 90 80 71 78 70 64 75 69 63 4 83 71 62 69 61 55 67 60 54 5 76 63 54 62 54 47 60 53 47 6 70 57 48 56 48 42 54 47 41 7 65 52 43 51 43 37 50 42 37 8 61 47 39 47 39 33 45 38 33 9 57 44 35 43 35 30 42 35 30 10 53 40 32 40 32 27 39 32 27
RCR
Zonal Lumen Summary Zone Lumens % Lamp % Fixture 0 - 30 703 29.0 29.0 0 - 40 1123 46.3 46.3 0 - 60 1906 78.6 78.6 0 - 90 2425 100.0 100.0 90 - 180 0 0.0 0.0 0 - 180 2425 100.0 100.0
Efficiency: 100.0%
2VTL2 36L ADP L835, 3617 delivered lumens, test no. LTL20407, tested in accordance to IESNA LM-79
90 200 400 600 800 1000 1200 0 0 20 90 40 80
60
CP Summary 0 90 0 1274 1274 5 1262 1273 15 1200 1230 25 1081 1149 35 918 1038 900 45 726 743 55 524 576 65 332 366 75 164 87 85 37 2 2 90
Coefficients of Utilization pf 20% pc 80% 70% 50% pw 70%50%30% 50%30%10% 50%30%10% 0 119 119 119 116 116 116 111 111 111 1 108 103 99 101 97 93 97 94 90 2 98 90 83 88 81 76 84 79 74 3 90 79 70 77 69 63 74 67 62 4 82 70 61 68 60 53 66 58 53 5 75 62 53 61 52 46 59 51 46 6 69 56 47 55 46 40 53 46 40 7 64 51 42 50 42 36 48 41 35 8 60 46 38 46 37 32 44 37 32 9 56 43 34 42 34 29 41 33 28 10 53 39 31 39 31 26 38 31 26
RCR
Zonal Lumen Summary Zone Lumens % Lamp % Fixture 0 - 30 977 27.0 27.0 0 - 40 1590 44.0 44.0 0 - 60 2793 77.2 77.2 0 - 90 3617 100.0 100.0 90 - 180 0 0.0 0.0 0 - 180 3617 100.0 100.0
Efficiency: 100.0%
Mounting Data
9/16 15/16
Dimensions
All dimensions are inches (centimeters) unless otherwise specified.
SS
POWER INPUT
LIGHT OUTPUT LIGHT OUTPUT POWER INPUT
Saved Energy
POWER INPUT
POWER INPUT
LIGHT OUTPUT
Wasted Energy
LIGHT OUTPUT
80% 0 10 20 THOUSAND OPERATING HOURS 30 40 29W 50 80% 0 10 20 THOUSAND OPERATING HOURS 30 40 29W 50
Notes 1 With nlight 80% lumen management input watts start at 29 and gradually increasing to 36 at 50,000 hrs when using 36L system.
2VTLED-2X2
LED:
Phone: 800-858-7763
Fax: 770-929-8789
www.lithonia.com
Rev. 09/10/12
Round 4 LED
Aisle/Stack Direct
Suspended 4 Round
S P E C I F I C AT I O N S
DIMENSIONS
RD4MS (ASO)
Two LED Lumen Packages:
Specify by Lamp Wattage W20 Low 1550 20 W40 High 3000 40
RD4MS (ASO)
__________ __________ __________ __________ __________ __________ __________ __________ __________ __________ __________ __________ __________ __________ _____________________
* nominal per 4
SPECIFICATIONS
Construction
Extruded aluminum housing has diameter of 4. Die-cast aluminum end caps mechanically attach with no exposed fasteners.
Source
Finish
Standard nish for housing and end caps is painted aluminum or gloss white. Consult factory for custom colors.
Controls
Environment
Two LED lumen packages (High and Low). Three available color temperature options (3000K, 3500K and 4000K).
Optics
Optional nLight-embedded controls allow for constant lumen management (N80) and facilitate simple plug-and-play networking and control via CAT-5e cable.
Electrical
4 and 8 lengths in a single section for exact suspension spacing of 4 and 8. For total luminaire length, add 3 for each end cap. Using internal joiners, 4 and 8 sections can be joined to form longer rows.
Validation
Optical system consists of injection-molded primary optics, co-extruded acrylic lenses and metal reectors. Lenses connect end to end to form a continuous line of light.
Dimming
LED light engine consists of modular LED boards and 0-10V dimming driver rated 50,000 hours (L80) at 25 C ambient temperature. Driver input wattage is 20W for 1550 delivered-lumen package and 40W for 3000 delivered-lumen package per 4 section. Specify 120V or 277V. Pre-wired with 16AWG xture wire. For special circuiting or wire gauge, consult factory. Plug-in electrical connectors included.
CSA/CUS listed. FCC part 15 certied. LM-79 tested. Lighting Facts partner.
Warranty
Five-year limited warranty coverage includes luminaire construction, LED light engine, driver and nLight control device. Terms and conditions apply.
Packaging
100% post-consumer recycled cardboard box. Biodegradable foam inserts and protective luminaire bag. Recycled kraft paper tape.
CATALOG NUMBER
Example:
__________ RD4MS W40 ASO 32FT R8 120 EZB SCT LP835 F1/48 C032 DL
_________
__________
__________
__________
__________
Fixture
RD4MS
Lamp Wattage
W20 1550 nominal deliveredlumens W40 3000 nominal deliveredlumens
Shielding
ASO Aisle/ stack option
Voltage
120 277
Driver Type
EZB eldoLED dims to black
______________
________________
______________ ______________
______________
_________________________________
Switching
SCT Single circuit
Mounting Type
F1/
Overall Suspension2
24 24 36 36 48 48 72 72 XX XX Overall suspension is measured from ceiling to bottom of xture
Finish
C032 White white (high gloss) C110 Painted aluminum C099 Custom nish
Options
BLK3 CP DL ELH4 GLR GMF LM MCS N80 N100 OJB SLP Black cord, cord manager and canopy Chicago plenum (available with F1A only) Damp location label Emergency through wiring w/separate feed Fusing (fast blow) Fusing (slow blow) 80% lumen management without networking Matching feed canopy at support nLight nIO with 80% lumen management per row/zone nLight nIO without lumen management per row/zone Offset junction box Sloped ceiling adapter (for 10-45; must be specied along with F2 and OJB options) XXXX Integrated sensor; choose options and obtain code on page 2
T-bar ceiling (universal mounting bracket) F1A/ T-bar ceiling (UMB with integrated J-box) F2/ Hard ceiling (horizontal J-box)
Notes:
1 Emergency type is installed in last 4 of luminaire sections. Separate feed required 2 Adjustable cable gripper comes standard
3 Not available with N80 and N100 4 No dimming control on emergency feed
2246 5th Street, Berkeley, CA 94710 Tel: 510.845.2760 Fax: 510.845.2776 Email: techsupport@peerlesslighting.com PeerlessLighting.com
2013 Acuity Brands Lighting, Inc. All Rights Reserved. Peerless is a registered trademark of Acuity Brands Lighting. Products in this document may be covered by one or more U.S. Patents and Patents Pending. Specications subject to change without notice. 1-year limited warranty. Complete warranty terms located at www.acuitybrands.com/customerresources/terms_and_conditions.aspx
Round 4 LED
Aisle/Stack Direct
Suspended 4 Round
INTEGRATED NLIGHT MICRO SENSOR
EXAMPLE: PDT1 Sensor Type (choose one) ADC nLight model nES ADCX PDT nLight model nES PDT7 ADCX Daylight Dimming Specify 0-10V dimming ballast No occupancy sensing Daylight Dimming and/or Occupancy Detection Specify 0-10v dimming ballast for daylight dimming Specify xed-output ballast for occupancy detection only (daylight dimming disabled) 1* 2 3*
RD4MS (ASO)
Determine the appropriate sensor type, network type and sensor power source for your application. Enter the code in the Options section of the Catalog Number.
Network Type & Sensor Power Source (choose one) nLight-Enabled (Network-Ready) with Luminaire-Integrated Power Pack 10 Cat-5e cable and splitter provided Standalone Operation (No Networking) with Luminaire Integrated Power Pack No Cat-5e cable provided nLight-Enabled (Network-Ready) with Remote nLight Power Pack or nPanel 10 Cat-5e cable and splitter provided Order required remote nLight Power Pack or nPanel separately through nLight (Acuity Brands Controls)
For more information about the Integrated nLight Micro Sensor, its capabilities and options, download the PDF guide at: PeerlessLighting.com/nLight-Sensor-Guide *nLight-Enabled (network-ready) options include one RJ-45 connector on the luminaire, 10 feet of Cat-5e cable to control the entire luminaire row (depending on wattage/voltage limitations), and splitter. The Cat-5e cable drop is located in the same section as the sensor. For multiple zones, please contact techsupport@peerlesslighting.com.
4-14
18 LBS
34 LBS
PHOTOMETRICS
200
W20 LP835 75 lumens per watt 1484 delivered lumens 100% down
W40 LP835 69 lumens per watt 2876 delivered lumens 100% down
400
600
800
2246 5th Street, Berkeley, CA 94710 Tel: 510.845.2760 Fax: 510.845.2776 Email: techsupport@peerlesslighting.com PeerlessLighting.com
2013 Acuity Brands Lighting, Inc. All Rights Reserved. Peerless and Peerless Bruno are registered trademarks of Acuity Brands Lighting. Products in this document may be covered by one or more U.S. Patents and Patents Pending. Specications subject to change without notice. 1-year limited warranty. Complete warranty terms located at www.acuitybrands.com/customerresources/terms_and_conditions.aspx
Round 4 LED
Aisle/Stack Direct
LIGHTING FACTS LABELS
RD4MS (ASO)1484L3500K RD4MS (ASO)2876L3500K
Suspended 4 Round
RD4MS (ASO)
2246 5th Street, Berkeley, CA 94710 Tel: 510.845.2760 Fax: 510.845.2776 Email: techsupport@peerlesslighting.com PeerlessLighting.com
2013 Acuity Brands Lighting, Inc. All Rights Reserved. Peerless is a registered trademark of Acuity Brands Lighting. Products in this document may be covered by one or more U.S. Patents and Patents Pending. Specications subject to change without notice. 1-year limited warranty. Complete warranty terms located at www.acuitybrands.com/customerresources/terms_and_conditions.aspx
Contrail Parallels
Indirect-Direct T5/T5HO
S P E C I F I C AT I O N S
LAMPING OPTIONS
PLM9 G Lay in Grid PLM9 S Surface Mount
1 58 5 18 20 12
Suspended
PLM9
__________ __________ __________ __________ __________ __________ __________ __________ __________ _____________________
Finished Ceiling
17
Finished Ceiling
17
20
20
SPECIFICATIONS
Construction
Die-formed, pre-painted steel recessed housing. PLM9 G: Extruded aluminum xed-length suspension yokes. Steel ballast channel above ceiling. PLM9 S: Extruded aluminum surface-mounted housing. GrateOptic curved, crenulated diffuser is extruded opal acrylic, with opaque painted ends.
Shielding
Reectors Finish
Die-formed, specular aluminum reectors. Satin anodized nish on suspension yokes. Low gloss, white paint standard on surface mounted housing.
Electrical
switching option allows system to be switched to 50% power for compliance with common energy codes while maintaining luminaire appearance. UL and C-UL listed.
Luminaire Length
Specify 120V, 277V, or 347V. Prewired with prescribed circuits and quick connectors. Step
4 individual luminaire sections available. Overall luminaire length is 4 9. Luminaires mount to 4 grid or specify surface mounted option.
CATALOG NUMBER
Examples:
________ PLM9 G 2 54T5HO U4 277 GEB80S SCT LP830
________
________
________
________
________
________
Lamp Type
28T5 28W T5 54T5HO 54W T5HO
Nominal Length
U4 4
Voltage
120 277 3471
Ballast Type
GEB10 <10% THD Electronic GEB952,3 <10% THD, .95 BF 2,3 GEB 115 <10% THD, 1.15 BF GEB801,3 <10% THD, .80 BF Dim Ballasts Available <10% THD, .95 BF step dim GEB95S2,3 GEB80S1,3 <10% THD, .80 BF step dim GEB115S2,3 <10% THD, 1.15 BF step dim 3 DMHL3D Lutron Hi-Lume dim 1,3 OSDIM Osram 0-10v dim Reference Ballast Wizard on website or consult factory for other options.
________
________
_________________________________
Switching
SCT Single circuit
Lamp Color
L/LP LP830 LP835 LP841 No lamp 3000k 80+ CRI 3500k 80+ CRI 4100k 80+ CRI
Options
CP GLR GMF NYC Chicago plenum (available with F1A only) Fusing (fast blow) Fusing (slow blow) New York City code
Available with T5 only: 3000K 80+ CRI Premier LP830P LP835P 3500K 80+ CRI Premier LP841P 4100K 80+ CRI Premier Reference Lamp Chart on website or consult factory for other options.
Notes:
2246 5th Street, Berkeley, CA 94710 Tel: 510.845.2760 Fax: 510.845.2776 Email: techsupport@peerlesslighting.com PeerlessLighting.com
2012 Acuity Brands Lighting, Inc. All Rights Reserved. Peerless and Contrail are registered trademarks of Acuity Brands Lighting. Products in this document may be covered by one or more U.S. Patents and Patents Pending. Specications subject to change without notice. 1-year limited warranty. Complete warranty terms located at www.acuitybrands.com/customerresources/terms_and_conditions.aspx
Contrail Parallels
Indirect-Direct T5/T5HO
Suspended
MOUNTING DETAIL (SURFACE)
Junction Box Ceiling
PLM9
5 18 Ballast Channel Note: Mount Spacing is the same for 4FT & 5FT luminaire.
4-2 4-9
16 LBS
20
4 FT FIXTURE
PLAN VIEW
PHOTOMETRICS
2-LAMP T5HO (ONE WING SHOWN) 88.6% efficiency 4432 delivered lumens 89.1% up / 10.9% down
2246 5th Street, Berkeley, CA 94710 Tel: 510.845.2760 Fax: 510.845.2776 Email: techsupport@peerlesslighting.com PeerlessLighting.com
2012 Acuity Brands Lighting, Inc. All Rights Reserved. Peerless and Contrail are registered trademarks of Acuity Brands Lighting. Products in this document may be covered by one or more U.S. Patents and Patents Pending. Specications subject to change without notice. 1-year limited warranty. Complete warranty terms located at www.acuitybrands.com/customerresources/terms_and_conditions.aspx
Type
Indoor Decorative
Wing
Vanity
Linear T5 Fluorescent
DIMENSIONS
Nominal Size 2' Lamp Configuration Model Number 10842RET5 10843RET5 10844RET5 Number of Lamps (2) 14W linear T5 (2) 21W linear T5 (2) 28W linaer T5 (A) Width inches (cm) 6-9/16" (16.7) 6-9/16" (16.7) 6-9/16" (16.7) (B) Length inches (cm) 22-5/8" (57.5) 37-5/8" (94.3) 48-7/8" (121.9) (C) Extension* inches (cm) 3-1/4" (8.3) 3-1/4" (8.3) 3-1/4" (8.3)
(A) (B)
3' 4'
(C)
ORDERING INFORMATION
For shortest lead times, configure products using bolded options. BNP
Series1,2 10842RET5 10843RET5 10844RET5 (2 - (2) 14W linear T5 3000K fluorescent lamps included (3 - (2) 21W linear T5 3000K fluorescent lamps included 4 - (2) 28W linear T5 3000K fluorescent lamps included
Ballast/Voltage2 (blank) 120-volt residential electronic ballast (standard) (Other voltage and ballast types consult factory)
Notes
1 2 Includes (2) linear T5 3000K fluorescent lamps. Use with non-dimmable switches only.
SHEET #: WINV
DEC-303
DECORATIVE & RESIDENTIAL: One Lithonia Way Conyers, GA 30012 Phone: 800.748.5070 Fax: 770.860.3903 www.lithonia.com 2008-2013 Acuity Brands Lighting, Inc. All rights reserved. Rev. 01/24/2013
4 Evo
OPTICAL SYSTEM Self-anged semi-specular, matte-diffuse or specular lower reector Patented Bounding Ray optical design (U.S. Patent No. 5,800,050) 45 cutoff to source and source image Top-down ash characteristic MECHANICAL SYSTEM 16-gauge galvanized steel construction; maximum 1-1/2 ceiling thickness Telescopic mounting bars maximum of 32 and minimum of 15, preinstalled, 4 vertical adjustment Toolless adjustments post installation Junction box capacity: 8 (4 in, 4 out ) 12AWG rated for 90C Light engine and driver accessible through aperture
ELECTRICAL SYSTEM Fully serviceable and upgradeable lensed LED light engine 70% lumen maintenance at 60,000 hours based on IESNA LM-79-2008 120-277VAC, 50/60hz power supply with 0-10V dimming (10-100%); rated for 50,000-hour life Overload and short circuit protected LEDs tested under LM80 LISTINGS Fixtures are CSA certied to meet US and Canadian standards; wet location, covered ceiling WARRANTY 5-year limited warranty. Complete warranty terms located at: www.acuitybrands.com/CustomerResources/Terms_and_conditions.aspx
Series EVO
Color temperature 27/ 30/ 35/ 41/ 2700 K 3000 K 3500 K 4100 K
Nominal lumen values 06 10 14 18 20 600 lumens 1000 lumens 1400 lumens 1800 lumens 2000 lumens
Aperture/Trim color 4AR 4PR 4WTR 4GR 4WR1 Clear Pewter Wheat Gold White
Distribution (blank) MD WD 1.0 s/mh Medium (0.8 s/mh) Wide (1.5 s/mh)
Driver (blank)2 ECOS23,4 ECOS32,3 0-10V dimming driver. Minimum dimming level 10% Lutron Hi-Lume 2-wire forward-phase dimming driver. Minimum dimming level 1% Lutron Hi-Lume 3-wire or EcoSystem dimming driver. Minimum dimming level 1%
Options SF RRL NEPP NSD5 TRW6 Single fuse RELOC-ready luminaire. Provides compatibility with Lithonia RELOC system. Access above ceiling required. Interface for Sensor Switch nLight network with integral power supply. Refer to TN-623-01. Sensor Switch nLight dimming relay White painted ange TRBL EL7 ELR7 CP8 BGTD Black painted ange Emergency battery pack with integral test switch Emergency battery pack with remote test switch Chicago plenum Bodine generator transfer device
ACCESSORIES order as separate catalog numbers (shipped separately) SCA4 CTA4-8 YK ISD BC Sloped ceiling adapter. Degree of slope must be specied (10D, 15D, 20D, 25D, 30D). Ex: SCA4 10D. Refer to TECH-190. Ceiling thickness adapter (extends mounting frame to accommodate ceiling thickness up to 2). 0-10V wallbox dimmer. Refer to ISD-BC.
ORDERING NOTES
1. 2. 3. 4. 5. Not available with nishes. Refer to TECH-240 for compatible dimmers. Not available with NEPP option. 120V only. One 5A relay with one 0-10 VDC dimming output, shipped installed. Refer to nSP5-D. 6. 7. 8. Not available with white reector. For dimensional changes, refer to TECH-140. Access above ceiling required. Not available with CP option. Not available with EL or ELR options.
EVO-4-Open PAGE 1 OF 3
GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2010-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/09/13. Specications subject to change without notice.
Solid-State Lighting
7 [16.4] 616
15 7 8 [40.3]
3 [36.0] 14 16
Aperture: 4-5/16 (11) Ceiling Opening: 5-1/8 (13) Overlap Trim: 5-7/16 (13.8)
WATTAGE CONSUMPTION MATRIX LUMENS 2000 1800 1400 1000 600 WATTAGE 31 29 26 21 16 LUMENS per WATT 65 58 55 51 49
GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2010-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/09/13. Specications subject to change without notice.
EVO-4-Open PAGE 2 OF 3
Solid-State Lighting
Distribution Curve
Distribution Data
Output Data
Coefcient of Utilization
200
400 0 20
40
INPUT WATTS: 20.6, DELIVERED LUMENS: 1039.0, LM/W=50.4, 1.5 S/MH, TEST NO. LTL21209
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 80% 50% 30% 10% 119 119 119 110 107 105 101 97 93 93 88 83 86 80 75 79 73 68 73 66 62 68 61 56 63 56 51 58 52 47 54 48 44 20% 70% 50% 30% 10% 116 116 116 108 105 103 99 95 92 92 87 83 85 79 74 78 72 68 72 66 61 67 61 56 62 56 51 58 52 47 54 48 44 50% 50% 30% 10% 111 111 111 104 102 100 96 93 90 89 85 81 82 77 74 76 71 67 71 65 61 66 60 56 61 55 51 57 51 47 53 47 43
80
200
400 40 600 0 20
INPUT WATTS: 26.2, DELIVERED LUMENS: 1431.9, LM/W=54.7, 1.5 S/MH, TEST NO. LTL21213
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 80% 50% 30% 10% 119 119 119 110 107 105 101 97 93 93 88 83 86 80 75 80 73 68 74 67 62 68 61 57 63 57 52 59 52 48 55 48 44 20% 70% 50% 30% 10% 116 116 116 108 105 103 100 96 92 92 87 83 85 79 75 79 72 68 73 66 62 67 61 57 63 56 52 58 52 48 54 48 44 50% 50% 30% 10% 111 111 111 104 102 100 96 93 90 89 85 81 83 78 74 77 71 67 71 66 61 66 60 56 62 56 52 57 52 48 54 48 44
80
400
800 0 20
40
INPUT WATTS: 29.0, DELIVERED LUMENS: 1682.7, LM/W=58.0, 1.5 S/MH, TEST NO. LTL21149
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 80% 50% 30% 10% 119 119 119 110 107 105 101 97 93 93 88 83 86 80 75 79 73 68 73 67 62 68 61 56 63 56 52 59 52 48 55 48 44 20% 70% 50% 30% 10% 116 116 116 108 105 103 99 95 92 92 87 83 85 79 75 78 72 68 73 66 62 67 61 56 62 56 52 58 52 47 54 48 44 50% 50% 30% 10% 111 111 111 104 102 100 96 93 90 89 85 81 83 78 74 77 71 67 71 65 61 66 60 56 61 56 51 57 51 47 53 48 44
80
800 40 0 20
PHOTOMETRY NOTES
Tested in accordance with IESNA LM-79-08. Tested to current IES and NEMA standards under stabilized laboratory conditions. Actual performance may differ as a result of end-user environment and application. Actual wattage may differ by +/- 10% when operating between 120-277V +/- 10%. CRI: 83 typical. Consult factory or IES le for microgroove bafe, black cone or other photometric reports. GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2010-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/09/13. Specications subject to change without notice.
EVO-4-Open PAGE 3 OF 3
RCR
400
60
0 5 15 25 35 45 55 65 75 85 90
Zone Lumens % Lamp 0 - 30 913.1 54.3 0 - 40 1449.4 86.1 0 - 60 1680.5 99.9 0 - 90 1682.7 100.0 90 - 180 0.0 0.0 0 - 180 1682.7 *100.0 *Efficiency
RCR
60
0 5 15 25 35 45 55 65 75 85 90
Ave Lumens 716 738 73 934 265 986 445 743 458 203 182 4 6 1 1 0 0 0 0 0
Zone Lumens % Lamp 0 - 30 784.3 54.8 0 - 40 1242.2 86.8 0 - 60 1430.4 99.9 0 - 90 1431.9 100.0 90 - 180 0.0 0.0 0 - 180 1431.9 *100.0 *Efficiency
RCR
60
0 5 15 25 35 45 55 65 75 85 90
Ave Lumens 497 513 51 653 186 709 320 547 337 156 138 3 5 1 1 0 0 0 0 0
Zone Lumens % Lamp 0 - 30 557.2 53.6 0 - 40 894.6 86.1 0 - 60 1037.7 99.9 0 - 90 1039.0 100.0 90 - 180 0.0 0.0 0 - 180 1039.0 *100.0 *Efficiency
RCR
PHOTOMETRY
INPUT WATTS: 15.6, DELIVERED LUMENS: 757.7, LM/W=48.6, 1.6 S/MH, TEST NO. LTL21260
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 80% 50% 30% 10% 119 119 119 110 107 105 101 97 93 93 87 83 86 79 75 79 72 68 73 66 61 68 61 56 63 56 51 58 51 47 54 48 43 20% 70% 50% 30% 10% 116 116 116 108 105 103 99 95 92 92 86 82 84 79 74 78 72 67 72 66 61 67 60 56 62 56 51 58 51 47 54 47 43 50% 50% 30% 10% 111 111 111 104 102 100 96 93 90 89 85 81 82 77 73 76 71 67 71 65 61 65 60 55 61 55 51 57 51 47 53 47 43
80
60
0 5 15 25 35 45 55 65 75 85 90
Ave Lumens 349 361 36 463 133 520 234 393 245 117 105 2 4 1 1 0 0 0 0 0
Zone Lumens % Lamp 0 - 30 402.6 53.1 0 - 40 647.4 85.4 0 - 60 756.6 99.9 0 - 90 757.7 100.0 90 - 180 0.0 0.0 0 - 180 757.7 *100.0 *Efficiency
50% beam 10% beam 76.1 91.1 Inital FC Mounting Center Height Beam Diameter FC Diameter FC 1.2 11.2 5.8 8.6 11.5 8.0 0.6 15.3 3.1 11.7 6.2 10.0 0.4 19.4 1.9 14.9 3.9 12.0 0.3 23.5 1.3 18.0 2.6 14.0 0.2 27.5 1.0 21.1 1.9 16.0
50% beam 10% beam 75.3 90.7 Inital FC Mounting Center Height Beam Diameter FC Diameter FC 1.6 11.1 8.2 8.5 16.4 8.0 0.9 15.2 4.4 11.6 8.8 10.0 0.6 19.2 2.8 14.7 5.5 12.0 0.4 23.3 1.9 17.7 3.8 14.0 0.3 27.3 1.4 20.8 2.7 16.0
50% beam 10% beam 73.6 90.0 Inital FC Mounting Center Height Beam Diameter FC Diameter FC 2.4 11.0 11.8 8.2 23.7 8.0 1.3 15.0 6.4 11.2 12.7 10.0 0.8 19.0 4.0 14.2 7.9 12.0 0.5 23.0 2.7 17.2 5.4 14.0 0.4 27.0 2.0 20.2 3.9 16.0
50% beam 10% beam 74.3 90.7 Inital FC Mounting Center Height Beam Diameter FC Diameter FC 2.7 11.1 13.4 8.3 26.9 8.0 1.4 15.2 7.2 11.4 14.5 10.0 0.9 19.2 4.5 14.4 9.0 12.0 0.6 23.3 3.1 17.4 6.1 14.0 0.4 27.3 2.2 20.5 4.5 16.0
6 Evo
OPTICAL SYSTEM Self-anged semi-specular, matte-diffuse or specular lower reector Patented Bounding Ray optical design (U.S. Patent No. 5,800,050) 45 cutoff to source and source image Top-down ash characteristic MECHANICAL SYSTEM 16-gauge galvanized steel construction; maximum 1-1/2 ceiling thickness Telescopic mounting bars maximum of 32 and minimum of 15, preinstalled, 4 vertical adjustment Toolless adjustments post installation Junction box capacity: 8 (4 in, 4 out ) 12AWG rated for 90C Light engine and driver accessible through aperture
ELECTRICAL SYSTEM Fully serviceable and upgradeable lensed LED light engine 70% lumen maintenance at 60,000 hours based on IESNA LM-79-2008 120-277VAC, 50/60hz power supply with 0-10V dimming (10-100%); rated for 50,000-hour life Overload and short circuit protected LEDs tested under LM80 LISTINGS Fixtures are CSA certied to meet US and Canadian standards; wet location, covered ceiling WARRANTY 5-year limited warranty. Complete warranty terms located at: www.acuitybrands.com/CustomerResources/Terms_and_conditions.aspx
Series EVO
Color temperature 27/ 30/ 35/ 41/ 2700 K 3000 K 3500 K 4100 K
Nominal lumen values 10 14 18 22 1000 lumens 1400 lumens 1800 lumens 2200 lumens
Aperture/Trim color 6AR 6PR 6WTR 6GR 6WR1 Clear Pewter Wheat Gold White
Distribution (blank) VND ND MD WD 1.0 s/mh Very narrow (0.5 s/mh) Narrow (0.6 s/mh) Medium (0.8 s/mh) Wide (1.2 s/mh)
Options 0-10V dimming driver. Minimum dimming level 10% Lutron Hi-Lume 2-wire forward-phase dimming driver. Minimum dimming level 1% Lutron Hi-Lume 3-wire or EcoSystem dimming driver. Minimum dimming level 1% SF RRL NEPP NSD5 TRW6 Single fuse RELOC-ready luminaire. Provides compatibility with Lithonia RELOC system. Access above ceiling required. Interface for Sensor Switch nLight network with integral power supply. Refer to TN-623-01. Sensor Switch nLight dimming relay White painted ange TRBL EL7,8 ELR7,8 CP9 BGTD Black painted ange Emergency battery pack with integral test switch Emergency battery pack with remote test switch Chicago plenum Bodine generator transfer device
ECOS32,3
ACCESSORIES order as separate catalog numbers (shipped separately) SCA6 CTA4-8 YK GVRT ISD BC Sloped ceiling adapter. Degree of slope must be specied (10D, 15D, 20D, 25D, 30D). Ex: SCA6 10D. Refer to TECH-190. Ceiling thickness adapter (extends mounting frame to accommodate ceiling thickness up to 2). Vandal-resistant trim accessory. Refer to TECH-200. 0-10V wallbox dimmer. Refer to ISD-BC.
ORDERING NOTES
1. 2. 3. 4. 5. Not available with nishes. Refer to TECH-240 for compatible dimmers. Not available with NEPP option. 120V only. One 5A relay with one 0-10 VDC dimming output, shipped installed. Refer to nSP5-D. 6. 7. 8. 9. Not available with white reector. For dimensional changes, refer to TECH-140. Not available with CP option. Must specify 120 or 277V. Not available with EL or ELR options.
EVO-6-Open PAGE 1 OF 3
GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2010-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/09/13. Specications subject to change without notice.
Solid-State Lighting
1 [38.3] 15 16
Aperture: 6-1/4 (15.9) Ceiling Opening: 7-1/8 (18.1) Overlap Trim: 7-1/2 (19.1)
WATTAGE CONSUMPTION MATRIX LUMENS 2200 1800 1400 1000 WATTAGE 32 28 25 18 LUMENS per WATT 67 66 63 61
GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2010-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/09/13. Specications subject to change without notice.
EVO-6-Open PAGE 2 OF 3
Solid-State Lighting
Distribution Curve
Distribution Data
Output Data
Coefcient of Utilization
800 40 0 20
INPUT WATTS: 24.6, DELIVERED LUMENS: 1538.8, LM/W=62.6, 1.0 S/MH, TEST NO. LTL21127
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 20% 70% 50% 30% 10% 116 116 116 109 107 105 102 98 95 95 91 87 89 84 81 84 79 75 79 74 70 74 69 65 70 65 61 66 61 57 63 57 54
RCR
1200
40 20
INPUT WATTS: 28.1, DELIVERED LUMENS: 1858.1, LM/W=66.1, 1.1 S/MH, TEST NO. LTL20947
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 20% 70% 50% 30% 10% 116 116 116 109 107 105 102 98 95 95 91 87 89 84 80 84 78 74 79 73 69 74 68 64 70 64 60 66 60 56 62 57 53
RCR
1200 40 1800 0 20
PHOTOMETRY NOTES
Tested in accordance with IESNA LM-79-08. Tested to current IES and NEMA standards under stabilized laboratory conditions. Actual performance may differ as a result of end-user environment and application. Actual wattage may differ by +/- 10% when operating between 120-277V +/- 10%. CRI: 83 typical. Consult factory or IES le for microgroove bafe, black cone or other photometric reports.
EVO-6-Open PAGE 3 OF 3
GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2010-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/09/13. Specications subject to change without notice.
RCR
PHOTOMETRY
INPUT WATTS: 18.4, DELIVERED LUMENS: 1113.4, LM/W=60.5, 1.1 S/MH, TEST NO. LTL21133
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 20% 70% 50% 30% 10% 116 116 116 109 107 105 102 98 95 95 91 87 89 84 80 84 78 74 79 73 69 74 68 64 70 64 60 66 60 56 62 57 53
80
400
60
0 5 15 25 35 45 55 65 75 85 90
Zone Lumens % Lamp 0 - 30 822.0 73.8 0 - 40 1062.1 95.4 0 - 60 1112.7 99.9 0 - 90 1113.4 100.0 90 - 180 0.0 0.0 0 - 180 1113.4 *100.0 *Efficiency
80% 50% 30% 10% 119 119 119 111 108 106 103 99 96 97 92 88 90 85 81 85 79 75 79 73 69 75 69 64 70 64 60 66 60 56 63 57 53
50% 50% 30% 10% 111 111 111 105 103 101 98 95 93 93 89 86 87 83 79 82 77 74 77 72 69 73 68 64 69 63 60 65 60 56 61 56 53
50% beam 10% beam 56.3 77.2 Inital FC Mounting Center Height Beam Diameter FC Diameter FC 3.4 8.8 16.8 5.9 33.6 8.0 1.8 12.0 9.0 8.0 18.1 10.0 1.1 15.2 5.6 10.2 11.3 12.0 0.8 18.3 3.8 12.3 7.7 14.0 0.6 21.5 2.8 14.4 5.6 16.0
80
600
60
0 5 15 25 35 45 55 65 75 85 90
Zone Lumens % Lamp 0 - 30 1152.8 74.9 0 - 40 1470.5 95.6 0 - 60 1537.5 99.9 0 - 90 1538.8 100.0 90 - 180 0.0 0.0 0 - 180 1538.8 *100.0 *Efficiency
80% 50% 30% 10% 119 119 119 111 109 106 104 100 96 97 92 88 91 85 81 85 79 75 80 74 70 75 69 65 71 65 61 67 61 57 63 58 54
50% 50% 30% 10% 111 111 111 105 103 101 99 96 93 93 89 86 87 83 80 82 78 74 78 73 69 73 68 65 69 64 61 65 60 57 62 57 54
Inital FC Mounting Center Height Beam Diameter FC Diameter FC 4.9 8.6 24.4 5.7 48.8 8.0 2.6 11.8 13.1 7.7 26.2 10.0 1.6 14.9 8.2 9.8 16.4 12.0 1.1 18.0 5.6 11.9 11.2 14.0 0.8 21.2 4.1 13.9 8.1 16.0
80
600
60
0 5 15 25 35 45 55 65 75 85 90
Zone Lumens % Lamp 0 - 30 1374.7 74.0 0 - 40 1772.2 95.4 0 - 60 1856.8 99.9 0 - 90 1858.1 100.0 90 - 180 0.0 0.0 0 - 180 1858.1 *100.0 *Efficiency
80% 50% 30% 10% 119 119 119 111 108 106 103 99 96 97 92 88 90 85 81 85 79 75 79 74 69 75 69 65 70 64 60 66 61 57 63 57 53
50% 50% 30% 10% 111 111 111 105 103 101 98 96 93 93 89 86 87 83 79 82 77 74 77 72 69 73 68 64 69 64 60 65 60 56 62 56 53
Inital FC Mounting Center Height Beam Diameter FC Diameter FC 5.7 8.7 28.6 5.8 57.1 8.0 3.1 11.9 15.4 7.9 30.7 10.0 1.9 15.1 9.6 10.0 19.1 12.0 1.3 18.3 6.5 12.1 13.1 14.0 0.9 21.5 4.7 14.2 9.5 16.0
6 Incito Cylinder
Solid-State Lighting (US and International Patents Pending)
OPTICAL SYSTEM Self-anged, specular, semi-specular or matte-diffuse lower reector in combination with highly transmissive lens provides unparalleled performance and efciency. Patented Bounding Ray Optical Principle design (U.S. Patent No. 5,800,050) provides 45 cutoff to source and source image for a smooth transition from top of the reector to bottom. HOUSING Heavy-gauge aluminum housing with top deck for clean appearance. Provided with safety chain on ceiling and pendant units, allowing hands-free wiring connections. Matte white textured polyester powder paint nish standard. MOUNTING Ceiling mount provided with mounting pattern for direct installation to 4 octagonal or square junction box. Wall mount provided with mounting pattern for direct installation to 4 octagonal or square junction box. Pendant-mount entry provided for 3/8 National Pipe Thread stem. Additional pendant options available (see Accessories). Wires supplied by others. EXAMPLE: ICO CYL 30/60 6AR 30 120 FCM DWHG
ELECTRICAL SYSTEM Solid-state LED light engine available in 2700 K, 3000 K, 3500 K or 4000 K color temperatures. CRI: 85 typical. 0-10V driver standard with <1% dimming level. DALI driver available with <1% dimming level. DMX with RDM (remote device management) available with <1% dimming level. Rated system life of 50,000 hours at 70% output. LISTINGS Fixtures are CSA certied to meet US and Canadian standards. Wall mount suitable for wet locations. Ceiling and pendant mount suitable for wet locations, covered ceiling. WARRANTY 5-year limited warranty. Complete warranty terms located at: www.acuitybrands.com/CustomerResources/Terms_and_conditions.aspx
Color temperature 27/ 30/ 35/ 40/ 2700 K 3000 K 3500 K 4000 K
Nominal lumen values 20 25 30 35 40 45 50 55 60 651 2000 lumens 2500 lumens 3000 lumens 3500 lumens 4000 lumens 4500 lumens 5000 lumens 5500 lumens 6000 lumens 6500 lumens
Aperture/Trim color 6AR 6PR 6WTR 6GR 6WR2 Clear Pewter Wheat Gold White
Beam 20 25 30 35 40 45 55 60 65 70 20 beam angle 25 beam angle 30 beam angle 35 beam angle 40 beam angle 45 beam angle 55 beam angle 60 beam angle 65 beam angle 70 beam angle
Voltage
MVOLT
120 277
Driver (blank) DALIR DMXR3 0-10V dimming driver. Minimum dimming level <1% DALI dimming driver. Minimum dimming level <1% DMX with RDM (remote device management). Minimum dimming level <1%. Includes termination plug
Mounting4 FCM WM PM5 ACC6 Ceiling mount Wall mount Pendant 3/8 thread mount Aircraft cable and cord mount
Options Interface for Sensor Switch nLight network with integral power supply. Architectural Colors - Powder Paint7 DWHG Matte white (standard) DDB Dark bronze DBL Black NEPP3 DWH DMB DNA DSS DGC DTC DBR DSB Gloss white Medium bronze Natural aluminum Sandstone Charcoal grey Tennis green Bright red Steel blue
ACCESSORIES order as separate catalog numbers (shipped separately) CYS8 CRS8 3/8 stem and canopy with 5 hang straight swivel 3/8 stem and canopy with 45 swivel
ICO-CYL-6-Open PAGE 1 OF 4
GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2012-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/28/13. Specications subject to change without notice.
C D
Pendant/Wall Mount:
Aperture: 6-1/4 [15.8] Housing Diameter: 10-1/2 [26.7] Housing Height: 16-1/16 [40.8]
Ceiling Mount:
Aperture: 6-1/4 [15.8] Housing Diameter: 10-1/2 [26.7] Housing Height: 19-1/2 [49.6]
WATTAGE CONSUMPTION MATRIX BEAM ANGLES LUMENS 6500 6000 5500 5000 4500 4000 3500 3000 2500 2000 20 99W 93W 81W 73W 63W 55W 48W 40W 33W 26W 25 99W 93W 81W 73W 63W 55W 48W 40W 33W 26W 30 99W 93W 81W 73W 63W 55W 48W 40W 33W 26W 35 99W 93W 81W 73W 63W 55W 48W 40W 33W 26W 40 99W 93W 81W 73W 63W 55W 48W 40W 33W 26W 45 99W 93W 81W 73W 62W 55W 48W 40W 33W 55 99W 93W 81W 73W 62W 55W 48W 40W 33W 60 99W 93W 81W 73W 62W 55W 48W 40W 33W 65 99W 93W 81W 73W 62W 55W 48W 40W 33W 70 99W 93W 81W 73W 62W 55W 48W 40W 33W
ORDERING NOTES
1. 2. 3. 4. 5. Only available in 20 through 40 beam angles. Not available with nishes. Interface remote mounted. Wires supplied by others. Must specify stem and canopy. See Accessories. 6. 7. 8. 10 aircraft cable. Additional architectural colors available; see www.lithonia.com/archcolors. Color and length of stem must be specied (from 6 to 240 in even increments in maximum sections of 48). Ex.: CYS06 DWHG. Ceiling attachment for interior use. Consult factory for exterior use. Wire not included.
GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2012-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/28/13. Specications subject to change without notice.
ICO-CYL-6-Open PAGE 2 OF 4
Solid-State Lighting
Distribution Curve
Distribution Data
Output Data
Coefcient of Utilization
12800
25600
40 20
INPUT WATTS: 96.0, DELIVERED LUMENS: 6071.4, LM/W=63.2, 0.7 S/MH, TEST NO. LTL22193P158
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 20% 70% 50% 30% 10% 116 116 116 109 107 105 103 99 96 97 92 89 91 86 83 86 81 77 82 77 73 78 72 69 74 69 65 70 65 62 67 62 58
RCR
8000
40 20
INPUT WATTS: 101.0, DELIVERED LUMENS: 5948.3 LM/W=58.9, 1.2 S/MH, TEST NO. LTL22088P142
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 20% 70% 50% 30% 10% 116 116 116 108 105 103 99 95 91 91 86 82 84 78 74 78 71 67 72 65 61 67 60 56 62 56 51 58 51 47 54 48 44
RCR
1600
3200 0 20
40
PHOTOMETRY NOTES
Tested in accordance with IESNA LM-79-08. Tested to current IES and NEMA standards under stabilized laboratory conditions. Actual performance may differ as a result of end-user environment and application. Actual wattage may differ by +/- 10% when operating between 120-277V +/- 10%. CRI: 83 typical. Consult factory or IES le for microgroove bafe, black cone or other photometric reports. GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2012-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/28/13. Specications subject to change without notice.
ICO-CYL-6-Open PAGE 3 OF 4
RCR
PHOTOMETRY
INPUT WATTS: 95.0, DELIVERED LUMENS: 6367.8, LM/W=67.0, 0.3 S/MH, TEST NO. LTL22079P30
pf pc pw 0 1 2 3 4 5 6 7 8 9 10 20% 70% 50% 30% 10% 116 116 116 111 109 107 106 103 100 101 98 95 97 93 90 93 89 87 90 86 83 87 83 80 84 80 77 82 78 75 79 75 73
80
60
0 5 15 25 35 45 55 65 75 85 90
Zone Lumens % Lamp 0 - 30 5899.8 92.6 0 - 40 6269.6 98.5 0 - 60 6360.7 99.9 0 - 90 6367.8 100.0 90 - 180 0.0 0.0 0 - 180 6367.8 *100.0 *Efficiency
80% 50% 30% 10% 119 119 119 113 111 109 107 104 102 102 99 96 98 94 91 94 90 87 91 87 83 88 83 80 85 81 78 82 78 75 80 76 73
50% 50% 30% 10% 111 111 111 107 105 104 102 100 98 99 96 93 95 92 89 92 88 86 89 85 83 86 82 80 83 80 77 81 77 75 79 75 73
50% beam 10% beam 19.4 43.3 Inital FC Mounting Center Height Beam Diameter FC Diameter FC 106.2 4.4 530.6 1.9 1061.5 8.0 57.1 6.0 285.3 2.6 570.8 10.0 35.6 7.5 177.8 3.2 355.8 12.0 24.3 9.1 121.4 3.9 242.8 14.0 17.6 10.7 88.1 4.6 176.2 16.0
80
4000
60
0 5 15 25 35 45 55 65 75 85 90
Zone Lumens % Lamp 0 - 30 4832.2 79.6 0 - 40 5697.6 93.8 0 - 60 6062.1 99.8 0 - 90 6071.4 100.0 90 - 180 0.0 0.0 0 - 180 6071.4 *100.0 *Efficiency
80% 50% 30% 10% 119 119 119 111 109 107 104 101 97 98 93 90 92 87 83 87 82 78 82 77 73 78 73 69 74 69 65 71 65 62 67 62 59
50% 50% 30% 10% 111 111 111 105 104 102 99 97 94 94 91 88 89 85 82 84 80 77 80 76 72 76 72 68 73 68 65 69 65 61 66 62 58
Inital FC Center Beam Diameter FC Diameter FC 34.7 7.1 173.3 3.8 346.5 18.6 9.6 93.2 5.2 186.3 11.6 12.2 58.1 6.5 116.1 7.9 14.7 39.6 7.9 79.3 5.8 17.3 28.8 9.3 57.5
80
60
0 5 15 25 35 45 55 65 75 85 90
Zone Lumens % Lamp 0 - 30 3220.1 54.1 0 - 40 4773.3 80.2 0 - 60 5927.6 99.7 0 - 90 5948.3 100.0 90 - 180 0.0 0.0 0 - 180 5948.3 *100.0 *Efficiency
80% 50% 30% 10% 119 119 119 110 107 104 101 96 92 93 87 82 85 79 74 79 72 67 73 66 61 67 61 56 63 56 51 58 52 47 54 48 44
50% 50% 30% 10% 111 111 111 103 101 100 96 92 89 88 84 80 82 77 73 76 70 66 70 65 60 65 59 55 61 55 51 57 51 47 53 47 43
50% beam 10% beam 62.0 91.1 Inital FC Mounting Center Height Beam Diameter FC Diameter FC 12.6 11.2 63.1 6.6 126.2 8.0 6.8 15.3 33.9 9.0 67.9 10.0 4.2 19.4 21.1 11.4 42.3 12.0 2.9 23.4 14.4 13.8 28.9 14.0 2.1 27.5 10.5 16.2 20.9 16.0
CONTROLS
nCM PDT 9 nPOD DX
A A
OPTIONAL
Choose Wall Controls. nLIGHT offers multiple styles of wall controls each with varying features and user experience.
A
B
nPP16
A
B
Push-Button WallPod Traditional tactile buttons and LED user feedback Touch WallPod Contemporary capacitive touch style buttons with audible clicker for user feedback
C
nCM ADC
EXAMPLE Single Level Control with One Daylight Harvesting Zone Devices Installed: nPP16 Power Pack nPOD DX On/Off/Dim Touch WallPod nCM PDT 9 Ceiling Mount Dual Tech Occupancy Sensor nCM ADC Daylight Sensor with Automatic Dimming Control
Graphic WallPod Full color touch screen provides a sophisticated look and feel
Description: This design makes use of available daylight in the space by incorporating a standalone photocell device to automatically dim the lights in row B. Both rows of lights are turned on and off together by a single relay (in the power pack) and occupancy sensor. An On/Off/Dim Touch WallPod enables users to raise and lower row B as required.
GOTHAM ARCHITECTURAL DOWNLIGHTING | 1400 Lester Road Conyers GA 30012 | P 800.315.4982 | gothamlighting.com
2012-2013 Acuity Brands Lighting, Inc. All Rights Reserved. Rev. 10/28/13. Specications subject to change without notice.
ICO-CYL-6-Open PAGE 4 OF 4
INTENDED USE Provides a minimum of 90 minutes of illumination for the rated wattage upon loss of AC power. Ideal for applications requiring attractive unit equipment with quick installation. Certain airborne contaminants can diminish integrity of acrylic. Click here for Acrylic Environmental Compatibility table, for suitable uses. CONSTRUCTION White, compact, low-profile contemporary design. Engineering-grade thermoplastic housing is impact-resistant, scratch-resistant and corrosion-proof. UL94V-O flame rating. UV-stable resin resists discoloration from natural and man-made light sources. Two LED lamp heads with 12 series-parallel white LEDs each, provide redundant light sources to ensure emergency lighting performance. The typical life of the LED lamp is 10 years. Dual-voltage input capability (120/277V). Edge connector on printed circuit board ensures long-term durability. Low-profile, integrated test switch/pilot light. Easily visible bright red status indicator. Unique track-and-swivel arrangement permits full range of direction of lamp head adjustment. Universal J-box mounting pattern. Tool-less access for maintenance. Flexible conduit entry provision on top of the unit. Ceiling- or wall-mount standard. ELECTRICAL Current-limiting charger maximizes battery life and minimizes energy consumption. Provides low operating costs. Short-circuit protection current-limiting charger circuitry protects printed circuit board from shorts. Thermal compensation adjusts charger output to provide optimum charge voltage relative to ambient temperature. Regulated charge voltage maintains constant-charge voltage over a wide range of line voltages. Prevents over/undercharging that shortens battery life and reduces capacity. Filtered charger input minimizes charge voltage ripple and extends battery life. AC/LVD reset allows battery connection before AC power is applied and prevents battery damage from deep discharge. Single multi-color LED indicator to display two-state charging, test activation and three-state diagnostic test. Test switch provides manual activation of 30-second diagnostic testing for on-demand visual inspection. Selfdiagnostic testing for 30 seconds every 30 days, 30 minute every 180 days and 90 minutes annually. Diagnostic evaluation of LED light source, AC to DC transfer, charging and battery condition. Battery Sealed, maintenance-free nickel-cadmium battery delivers 90 minute capacity to emergency lamps. Two-state constant-current charge maximizes battery life and automatically recharges after battery discharge. Low-voltage disconnect prevents excessively deep discharge that can permanently damage the battery. Optional high-output battery available to power both local and optional LED remote lamp heads simultaneously. LISTINGS UL damp location listed standard 50-104F (10-40C). Meets UL 924, NFPA 101 (current Life Safety Code), NEC and OSHA illumination standards. WARRANTY 5-year limited warranty. Complete warranty terms located at www.acuitybrands.com/CustomerResources/Terms_and_conditions.aspx Actual performance may differ as a result of end-user environment and application. Note: Specifications subject to change without notice.
Type
ELM2 LED
LED Lamp Head Ni-Cad Battery
Lead times will vary depending on options selected. Consult with your sales representative.
Options HO SD NOM High-output ni-cad battery for 6W remote capacity Self-diagnostics Meets Mexican standards1
Accessories: 2,3,5 Order as separate catalog number. ELA Q L0304 ELA T Q L0304 ELA QWP L0304 ELA T QWP L0304 ELA WG1 Single LED indoor remote head, white Twin LED indoor remote head, white Single LED weather-proof remote head, gray Twin LED weather-proof remote head, gray Wireguard, 15 W x 13-1/2 H x 6 D4
Notes 1 Available in black or white. Consult factory for options. 2 Also available in black. Add "B" after ELA to order black finish. Example: ELA B Q L0304. 3 Only compatible with Quantum LED series. For use with self-diagnostics fixture, add SD to end of catalog number. Example: ELA Q L0304 SD. 4 See spec sheet ELA-WG. 5 See spec sheet ELA-Q-LED.
EMERGENCY ELM2_LED
MOUNTING
BATTERY
Ni-Cad (N)
Shelf Typical Optimum Voltage life2 life2 Maintenance3 temperature4 3.6 3 years 7-9 yrs. none 50-104F (10-40C)
1 Based on continuous operation. The typical life of the LED lamp is 10 years. 2 At 77F (25C). 3 All life safety equipment, including emergency lighting path of egress, must be maintained, serviced and tested in accordance with all National Fire Protection Association and local codes. Failure to perform the required maintenance, service or testing could jeopardize the safety of occupants and will void all warranties. 4 Optimum ambient temperature range where unit will provide capacity for 90 minutes. Higher and lower temperatures affect life and capacity. Consult factory for detailed information. 2-3/4 (7.0)
Mounting Plate
1/2 flexible conduit knockout
2-1/8 (5.4) 4-1/4 (10.8)
3-1/8 (7.9)
10-1/4 (26.0)
5-1/8 (13.0)
LAMP PHOTOMETRICS
QUANTUM LED SERIES SINGLE COVERAGE 3W Total White LEDs Using a single unit at a typical 7.5 mounting height delivers an average illuminance of 1.0 FC over a distance of 24 on a 3 path of egress and 18 on a 6 path of egress.
1 FC average
1 FC average
24' 3'
18'
6'
QUANTUM LED SERIES MULTIPLE COVERAGE 3W Total White LEDs Using multiple units at a typical 7.5 mounting height delivers 25 center-to-center spacing on a 3 path of egress and 20 center-to-center spacing on a 6 path of egress.
25'
1 FC average
1 FC average
20'
3'
6'
* Meets Life Safety Code standard minimum illuminance of 0.1 FC and average illuminance of 1.0 FC. Assumes open space with no obstructions, mounting height: 7.5, ceiling height: 9, and reflectances: 80/50/20. Analysis based on independently tested photometrics.
ELM2_LED
Phone: 800-334-8694
Fax: 770-981-8141
www.lithonia.com
2002-2012 Acuity Brands Lighting, Inc. All rights reserved. Rev. 12/06/12
Catalog Number
Notes
Type
MSL
LED Low Bay Complete Luminaire 4' or 8' Lengths
Dimensions All dimensions are shown in inches (centimeters) unless otherwise noted. SERIES TMSL MSL LENGTH 96 (243.8) 48 (121.9) WIDTH 10 (25.4) 10 (25.4) DEPTH 3-1/4 (8.26) 3-1/4 (8.26) WEIGHT 26 lbs. (11.8 kg) 13 lbs. (5.9 kg)
Lead times will vary depending on the options selected. Consult with your sales representative.
Lumens 4L 3L CLO 8L 6L CLO 4,100 lumens 3,300 lumens2 8,200 lumens 6,600 lumens2
1
Color temperature LP835 LP840 LP850 3500K, 83 CRI 4000K, 83 CRI 5000K, 83 CRI
Options (blank) PLR1G PLR22G PLR1LVG GLR CS93W CS11W CS1W MSI MSID CRE CRM End caps have flattened knockouts made for individual mounting Single-circuit, plug-in wiring Two-circuit alternating plug-in wiring Single-circuit plug-in wiring with low-voltage leads Internal fast-blow fuse4 600V SO white cord, no plug 6' white cord-set, twist-lock NEMA L7-15P, 277V4 6' white cord-set, straight blade NEMA 5-15P, 120V4 Aisle motion sensor, pre-wired4 Occupancy sensor,prewired, HI/LO dimming control 4 Continuous row end; one hole for wiring to row, one flattened knockout to terminate the row Continuous row middle; both end plates have holes for row wiring
Notes 1 DesignLights Consortium (DLC) qualified for MSL only. 2 2Refer to Constant Lumen Output (CLO) chart on page 2. 3 MVOLT 120-277 only. 4 Specify voltage. 5 One cable per package.
INDUSTRIAL
MSL
Ambient Rating (120V - 277V) -4F(-20C) to 86F(30C) -4F(-20C) to 86F(30C) -4F(-20C) to 86F(30C) -4F(-20C) to 86F(30C)
Delivered Lumens 3500K CCT @ 25C Ambient Temperature 4083 3266 8140 6512
Delivered Lumens 4000K CCT @ 25C Ambient Temperature 4064 3251 8102 6482
Delivered Lumens 5000K CCT @ 25C Ambient Temperature 4139 3311 8252 6601
Comparable Light Source 1-lamp 54T5HO, 2-lamp 32T8, 70-100W HID 1-lamp 54T5HO, 2-lamp 32T8, 70-100W HID 2-lamp 54T5HO, 4-lamp 32T8, 150-175W HID 2-lamp 54T5HO, 4-lamp 32T8, 150-175W HID
0 1
10,000 0.94
20,000 0.92
30,000 0.90
40,000 0.87
50,000 0.85
60,000 0.85
100,000 0.76
Lighting precision
Use the MS Series LED in open indoor spaces or for aisle lighting. Light-shaping reflectors and diffusers provide precise, custom optics while minimizing wasted light and hot spots. Color-temperature options give you three choices to best suit your application.
Energy efficiency
The MS Series LED cuts operational lighting costs by more than 40% over traditional T8 fluorescent lighting. The long life of the LED technology also means reduced maintenance-cycle costs, while the ability to dim the MS Series LED brings even greater energy savings.
The illustration shows a traditional source superimposed over the MS Series LED, and the wasted light that is eliminated to drive the lumens-per-watt to greater than 93.
Controls integration
For extra energy efficiency, pair the MS Series LED with occupancy sensors and photocontrols from Sensor Switch or Lighting Control & Design. In addition, daylighting products from Sunoptics provide tremendous cost savings by harvesting the light of the sun.
INDUSTRIAL
MSL
Dimensions
All dimensions are inches (centimeters).
3 1/4 (8.3)
10 (25.4)
THMS5HB
3 1/4 (8.3)
Flattened Knockout
3 1/4 (8.3)
3 1/4 (8.3)
Flattened Knockout
1-1/8" Hole
MSL
TMSL
Photometrics
See www.lithonia.com
MSL
INDUSTRIAL:
One Lithonia Way, Conyers, GA 30012 Phone: 800-315-4963 Fax: 770-981-8191 www.lithonia.com
2013 Acuity Brands Lighting, Inc. All rights reserved. Rev. 09/24/13
TWR2 LED
Type
Hit the Tab key or mouse over the page to see all interactive elements.
Introduction
The popular TWR2 luminaire is now available with long-lasting, energy-efficient LED technology. Featuring a classic dayform, the TWR2 LED offers a traditional appearance and is powered by advanced LEDs. The TWR2 LED luminaire is powerful yet energy efficient, capable of replacing up to a 400W metal halide luminaire while saving up to 82% in energy costs. Offering an expected service life of more than 20 years, the TWR2 LED eliminates frequent lamp and ballast replacements associated with traditional technologies.
Specications
Width: Height: Depth: Weight: 17
(43.2 cm)
D H W
9
(22.9 cm)
9-5/16
(23.6 cm)
17.2 lbs
(7.8 kg)
Ordering Information
TWR2 LED Series TWR2 LED Performance Package 1 6979 lumens Color Temperature 50K 5000K 1
Voltage MVOLT 2
NOTES 1 Correlated color temperature (CCT) shown is nominal per ANSI C78, 377-2008. MVOLT driver operates on any line voltage from 120277V (50/60 Hz).
The TWR2 LED combines traditional wall pack design with high-output LEDs to provide an energyefficient, low maintenance LED wall pack suitable for replacing up to 400W MH fixtures. The traditional shape helps maintain building aesthetics when replacing only a portion of your buildings wall packs. TWR2 LED is ideal for outdoor applications such as carports, loading areas, driveways and parking areas. CONSTRUCTION Rugged cast-aluminum housing with bronze polyester powder paint for lasting durability. Door is hinged on the side so door swings out of the way during installation and service. Castings are sealed with a one-piece gasket to inhibit the entrance of external contaminants. MVOLT driver operates on any line voltage from 120-277V (50/60Hz). Rated for outdoor installations, -40C minimum ambient.
INSTALLATION Designed for wall mounting above four feet from ground. Housing is configured for mounting directly over a standard 4 outlet box (by others) or for surface wiring via any of three convenient 1/2 threaded conduit entry hubs. LISTINGS UL Listed to U.S. and Canadian safety standards for wet locations. Tested in accordance with IESNA LM-79 and LM-80 standards. WARRANTY Five-year limited warranty. Full warranty terms located at www.acuitybrands.com/ CustomerResources/Terms_and_conditions.aspx.
OPTICS High-performance LEDs maintain up to 86% of light output at 100,000 hours of service life (L86/100,000 hours). Prismatic glass lens designed for superior lighting distribution, uniformity and fixture spacing. See Lighting Facts label and photometry reports for specific fixture performance.
Note: Specifications are subject to change without notice. Actual performance may differ as a result of end-user environment and application
One Lithonia Way Conyers, Georgia 30012 Phone: 800.279.8041 Fax: 770.918.1209 www.lithonia.com
2013 Acuity Brands Lighting, Inc. All rights reserved.
Performance Data
Lumen Output Lumen Ambient Temperature (LAT) Multipliers
Ambient
0C 10C 20C 25C 30C 40C 32F 50F 68F 77F 86F 104F Lumen values are from photometric tests performed in accordance with IESNA LM-79-08. Data is considered to be representative of the congurations shown, within the tolerances allowed by Lighting Facts. Actual performance may differ as a result of enduser environment and application. Use these factors to determine relative lumen output for average ambient temperatures from 0-40C (32-104F).
Lumen Multiplier
1.03 1.01 1.00 1.00 0.99 0.98
Performance Package
CCT
System Watts
5000K
79W
6,979
89
Photometric Diagrams
LEGEND 0.2 fc 0.5 fc 1.0 fc 2.0 fc
To see complete photometric reports or download .ies les for this product, visit the Lithonia Lighting TWR2 LED homepage. Tested in accordance with IESNA LM-79 and LM-80 standards
One Lithonia Way Conyers, Georgia 30012 Phone: 800.279.8041 Fax: 770.918.1209 www.lithonia.com
2013 Acuity Brands Lighting, Inc. All rights reserved. Rev. 03/19/13