SE3-12 SERIES
UP
UP
Notes
12" (305 mm) Reflector Prefinished semi-specular aluminum Bronze Polycarbonate Shroud
1/2"-14 NPT Threaded Hub
BOTTOM VIEW
WATTAGE CATALOG #
SPEC
SPEC #
MOUNTING POSITION #
SPEC #
SPEC #
SPEC #
SPEC #
SPEC #
PULSE START METAL HALIDE Wall Downlight 100W PSMH SE3410-(a)(b) Wall Downlight 150W PSMH SE3615-(a)(b) HIGH PRESSURE SODIUM Wall Downlight 100W HPS SE3510-(a)(b) Wall Downlight 150W HPS SE3515-(a)(b) FLUORESCENT Any 26/32/42W FL SE3242-(a)(b) Any 57W FL SE3257-(a)(b)
1 120V Reactor (100-150W HPS) 2 277V 27 277V Reactor (150W PSMH Only) 3 208V 4 240V 6L 347V (26 57W FL) (Canada Only) UL 120 277V Universal Voltage
(Standard: 26/32/42/57W FL)
For voltage availability outside the US and Canada, see Bulletin TD-9 or contact your Ruud Lighting authorized International Distributor.
GENERAL DESCRIPTION Aluminum die-cast housing supplied. Knockouts are provided on the back of the housing for 1/2" conduit entry or for mounting over a single gang box, 4" square or 4" octagon boxes. Two #8 x 1" threaded studs and nuts are provided for mounting over a junction box. Housing also includes 1/2"-14 NPT threaded hubs on four sides for conduit entry. 0.25 thick silicone sponge gasketing on the back of the housing provides a watertight mounting seal. Silicone sponge cord gasket between housing and lens ensures a water- and insect-tight seal. Injection molded clear poly carbonate lens and shroud assembly is held in place using a hidden spring clip assembly. Semi-specular reflector directs light downward to wash the wall below and to the sides of fixture. Extra wide cutoff distribution provides glare control and permits maximum spacing between fixtures.
ELECTRICAL Fluorescent fixture includes a 26, 32, 42 or 57W triple tube, compact fluorescent lamp. HID fixtures include a clear, medium-base lamp and porcelain enclosed, 4kv-rated screw-shell-type lampholder with spring-loaded center contact. Lamp ignitor included where required. HID and FL electronic ballast assemblies are high-power factor. Use the following circuit types: 120V Reactor 100 150W HPS 277V Reactor 150W PSMH HX High Reactance 100 150W PSMH; 100 150W HPS Electronic (120 277V Universal Voltage [50/60Hz] & 347V [60Hz]) (minimum starting temperature 0F [-18C]) 26/32/42/57W FL
LABELS ANSI lamp wattage label supplied, visible during relamping. ULListed in the US and Canada for wet locations and enclosure classified IP54 per IEC 529 and IES 598. FINISH Housing is standard with our exclusive Colorfast DeltaGuard finish, featuring an E-coat epoxy primer with bronze ultra-durable powder topcoat, providing excellent resistance to corrosion, ultraviolet degradation and abrasion. The finish is covered by our seven-year limited warranty. ACCESSORIES
TPS-1 Tamperproof Screwdriver
2011 Ruud Lighting, Inc. A Cree Company. All rights reserved. The information in this document is subject to change without notice. 9201 Washington Avenue Racine, Wisconsin 53406-3772 PHONE: (800) 236-7000 FAX: (800) 236-7500 WEB: www.ruudlightingdirect.com
Rev. 05/02/12
SE3-12 SERIES
90
2000
30
60
6000
Maximum Candlepower: 5024 Plane of Maximum CP: 82.5 Vertical Angle of Maximum Candlepower: 72.5 Lumen Rating: 14000
efficiencY = 71.1%
Footcandle readings for mounting heights other than 15' (4.6 m) may be obtained by multiplying fc values by the following:
.5 .3
2000 4000
.1 .05
6000
30
8.0' (2.4 m) 10.0' (3.0 m) 12.0' (3.7 m) 20.0' (6.1 m) 25.0' (7.6 m)
60
HEIGHT
4 0
Isofootcandle plot of 150W PSMH Square Perimeter Cutoff fixture at 15' (4.6 m) mounting height. (Plan view)
100M100Y
2011 Ruud Lighting, Inc. A Cree Company. All rights reserved. The information in this document is subject to change without notice. 9201 Washington Avenue Racine, Wisconsin 53406-3772 PHONE: (800) 236-7000 FAX: (800) 236-7500 WEB: www.ruudlightingdirect.com
ontaje
Rev. 05/02/12