Anda di halaman 1dari 3

CDMA 2000 1X Key Perfomance Indicators

The Key Perfomance Indicators are defined with target values.


Subsystem RAN RAN RAN RAN RAN RAN RAN

Type VOICE

KPI

Methods

Target Value1

Comments

Call Origination Success Rate Call Termination Success Rate

Dropped Call Rate

Soft Handoff Success Rate

No. of calls that reach assignment complete / No. of calls initiated by user No. of calls that reach assignment complete / No. of calls initiated to user No. of unitended call releases / No. of calls reaching assignment complete No. of soft handoff completed / No soft handoff requested No. of softer handoff completed / No. of softer handoff requested No. of handoff complete / No. of hard handoff requested Time between Origination Message sent and Assignment Complete Message received FER is normally measured by counting only Full Rate frame errors divided by the number of Full Rate frames FER is normally measured by

> 98% > 95%

Refer to Figure 1 in Appendix for detail call flow Refer to Figure 2 in Appendix for detail call flow

< 2%

> 99%

Softer Handoff Success Rate

> 99% > 90%

Hard Handoff Success Rate Call Setup Time (Latency)

< 3 sec < 2% (in 95 % of geographic bins) < 2%

Refer to Figure 1 in Appendix for detail call flow

Forward Frame Error Rate

FER should be measured over the RAN period of a typical call, about 100120 seconds FER should be measured over the RAN

Reverse Frame Error Rate

Call Blocking Rate (or GoS)Air Interface Call Blocking Rate (or GoS)MSC-PSTN Mobile Originated Packet Data Call Air Interface Call Setup Time DATA Mobile Originated Packet Data Call PPP Call Setup Time

counting only Full Rate frame errors divided by the number of Full Rate frames Percentage of voice channel service request being blocked at Air Interface Percentage of voice circuit service request being blocked at MSCPSTN Interface Time measured between Mobile sending Origination Message and Mobile sending the Service Connect Completion Message Time Between first LCP config Request and last IPCP config Ack

(in 95 % of geographic bins) < 2%

period of a typical call, about 100120 seconds Voice channel service request is blocked when voice channel resource is not available Voice circuit service request is blocked when voice circuit resource is not available Refer to Figure 1 in Appendix for detail call flow. Refer to figure 4 in Appendix for complete Packet Date Call Setup Call Flow Refer to Figure 3 in Appendix for detail call flow. Refer to figure 4 in Appendix for complete Packet Date Call Setup Call Flow PPP session is torn down first by exchanging LCP Terminate Requests/Acks . Once PPP is terminated, the air interface is released by sending a Release Order and associated acknowledgements Measured at PDSN RAN

MSC

< 1%

< 2 Sec

RAN & PDSN

< 6 Sec

PDSN

Mobile Originated Call Teardown Time

This includes the time taken to teardown both the PPP link as well as the air interface channel

< 0.5 Sec

RAN & PDSN

PPP Setup Failure Rate End-to-End Delay Connection Drop Rate Average Single User Throughput Stationary AverageSectorThroughput Stationary

No. of failed PPP setups/ No. of total PPP setup attempts Ping Statistics No. of Service Loss / No.of successful connection setups Throughput measured at application layer Throughput measured at application layer

PDSN

<5% 70-200 ms2 < 2% > 70 kbps > 200 kbps

Service loss after a connection has been established Measured at a single user stationary under a sector Aggregated user throughputs from multiple users under the same sector

RAN & PDSN RAN RAN

EVDO Key Perfomance Indicators


The Key Perfomance Indicators are defined with target values
Type KPI 1X EVDO Session Setup Time Methods Time measured between UATI Request Msg and the last Connection Close Msg AT initiated Connection Setup Time Time measured between Connection Request to Traffic Channel Complete AN Initiated Connection Setup Time Time measured between Page Msg and to Traffic Channel Complete PPP Session Setup (Simple IP) Time measured between first LCP Config Req and last IPCP Config Ack PPP Session Setup (Mobile IP) Time measured between first LCP Config Req and last IPCP Config Ack PPP Session Setup Failure Rate No. of failed PPP setups / No. of total PPP setup attempts End-to-End Delay Ping Statistics Average Sector Throughput-Reverse Throughput measured at application layer Link Average Sector Throughput-Forward Throughput measured at application layer Link Target Value3 < 6 sec 90 % of the time < 1.5 sec 90 % of the time < 5 sec 90 % of the time < 6 sec 90 % of the time < 6 sec 90 % of the time < 5% 70-270 ms4 > 200 kbps > 1 Mbps

DATA

1 2

Target Value is subject to carrier's expectation based on original network design plan. The values shown in the table are for REFERENCE ONLY. The round trip depends on the payload size of the ICMP packet. The target value is based on ICMP payload size between 8 to 56 bytes 3 Target value is subject to carrier's expectation based on original network design plan. The values shown in the table are for REFERENCE ONLY. 4 The round trip time depends on the payload size of the ICMP packet. The target value is based on ICMP payload size between 8 to 56 bytes

Anda mungkin juga menyukai