M68000
Addendum To
GT
GT
X R GT
11-1
Replace the table following paragraph 11.1. with the following table.
This document contains information on a product under development. Motorola reserves the right to change or discontinue this product without notice.
Case Packages 740-03 767-02 754-01 765A-05 765A-05 778-02 779-02 847-01 840B-01
Suffix L P R&P R RC FN FN FC FU
Pins 64 48 64 68 68 52 68 68 64
68000 X
68008
68010
68HC000
68HC001
68EC000
X X X X X X X X X X X X X X X X X X X
Note: 1. L = Cermic DIP P = Plastic DIP RP = Plastic Pin Grid Array RC = Pin Grid Array, Gold Lead Finish FN = Plastic Quad Pack (PLCC) FC = Plastic Quad (Gull Wing) FU = Plastic Quad Flat Pack (14 x 14mm) Note: 2. For ordering information refer to Hi-Perfomrance Embedded Systems Division Fact Sheet SG167/D. This document is published quarterly and may be ordered from the Literature Distribution Center or from your local sales office.
Page 11-4
Description In Figure 11-3 68-Lead Quad Pack (1 of 2). Pins 13 and 14 are labeled incorrectly. Pin 13 should be labeled BR not BGACK. Pin 14 should be VCC not BR.
11-5
In Figure 11-3 68-Lead Quad Pack (2 of 2). Pin 31 is labeled incorrectly. Pin 31 should be labeled A0 not NC.
11-7
In Figure 11-6. 64-Lead Quad Flat Pack. Add FU Suffix after 64-Lead Quad Flat Pack.
11-7
11-10
MOTOROLA
D5 D6 D7 D8 D9 D10 D11
49 48 D12 D13 D14 D15 A23 A22 A21 VCC A20 A19 A18 A17 A16 A15 A14 A13 33 32
MC68EC000
16 17
11-14
MOTOROLA
Motorola reserves the right to make changes without further notice to any products herein. Motorola makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does Motorola assume any liability arising out of the application or use of any product or circuit, and specifically disclaims any and all liability, including without limitation consequential or incidental damages. "Typical" parameters can and do vary in different applications. All operating parameters, including "Typicals" must be validated for each customer application by customer's technical experts. Motorola does not convey any license under its patent rights nor the rights of others. Motorola products are not designed, intended, or authorized for use as components in systems intended for surgical implant into the body, or other applications intended to support or sustain life, or for any other application in which the failure of the Motorola product could create a situation where personal injury or death may occur. Should Buyer purchase or use Motorola products for any such unintended or unauthorized application, Buyer shall indemnify and hold Motorola and its officers, employees, subsidiaries, affiliates, and distributors harmless against all claims, costs, damages, and expenses, and reasonable attorney fees arising out of, directly or indirectly, any claim of personal injury or death associated with such unintended or unauthorized use, even if such claim alleges that Motorola was negligent regarding the design or manufacture of the part. Motorola and are registered trademarks of Motorola, Inc. Motorola, Inc. is an Equal Opportunity/Affirmative Action Employer.