8 A Continuous On-State Current 80 A Surge-Current Glass Passivated Wafer 400 V to 800 V Off-State Voltage Max IGT of 20 mA
K A G
1 2 3 TO-220 PACKAGE (TOP VIEW)
absolute maximum ratings over operating case temperature (unless otherwise noted)
RATING TIC116D Repetitive peak off-state voltage TIC116M TIC116S TIC116N TIC116D Repetitive peak reverse voltage TIC116M TIC116S TIC116N Continuous on-state current at (or below) 70C case temperature (see Note 1) Average on-state current (180 conduction angle) at (or below) 70C case temperature (see Note 2) Surge on-state current at (or below) 25C case temperature (see Note 3) Peak positive gate current (pulse width 300 s) Peak gate power dissipation (pulse width 300 s) Average gate power dissipation (see Note 4) Operating case temperature range Storage temperature range Lead temperature 1.6 mm from case for 10 seconds IT(RMS) IT(AV) ITM IGM PGM PG(AV) TC Tstg TL VRRM VDRM SYMBOL VALUE 400 600 700 800 400 600 700 800 8 5 80 3 5 1 -40 to +110 -40 to +125 230 A A A A W W C C C V V UNIT
NOTES: 1. These values apply for continuous dc operation with resistive load. Above 70C derate linearly to zero at 110C. 2. This value may be applied continuously under single phase 50 Hz half-sine-wave operation with resistive load. Above 70C derate linearly to zero at 110C. 3. This value applies for one 50 Hz half-sine-wave when the device is operating at (or below) the rated value of peak reverse volta ge and on-state current. Surge may be repeated after the device has returned to original thermal equilibrium. 4. This value applies for a maximum averaging time of 20 ms.
PRODUCT
INFORMATION
1
APRIL 1971 - REVISED SEPTEMBER 2002 Specifications are subject to change without notice.
5: This parameter must be measured using pulse techniques, tp = 300 s, duty cycle 2 %. Voltage sensing-contacts, separate from the current carrying contacts, are located within 3.2 mm from the device body.
thermal characteristics
PARAMETER RJC RJA Junction to case thermal resistance Junction to free air thermal resistance MIN TYP MAX 3 62.5 UNIT C/W C/W
PRODUCT
2
INFORMATION
APRIL 1971 - REVISED SEPTEMBER 2002 Specifications are subject to change without notice.
THERMAL INFORMATION
AVERAGE ON-STATE CURRENT DERATING CURVE
PA - Max Continuous Anode Power Dissipated- W 16 IT(AV) - Maximum Average On-State Current - A 14 12 0 10 Continuous DC 8 6 4 2 0 30 = 180 180 Conduction Angle
TI03AA
10
40
50
60
70
80
90
100
110
01 01
10
100
TC - Case Temperature - C
Figure 2.
10
TC 70C No Prior Device Conduction Gate Control Guaranteed 1 1 10 Consecutive 50 Hz Half-Sine-Wave Cycles 100
Figure 3.
Figure 4.
PRODUCT
INFORMATION
3
APRIL 1971 - REVISED SEPTEMBER 2002 Specifications are subject to change without notice.
TYPICAL CHARACTERISTICS
GATE TRIGGER CURRENT vs CASE TEMPERATURE
TC03AA
VAA =12 V IGT - Gate Trigger Current - mA tp(g) 20 s 10 VGT - Gate Trigger Voltage - V RL = 100 08
06
1 -50
-25
25
50
75
100
125
0 -50
-25
25
50
75
100
125
TC - Case Temperature - C
TC - Case Temperature - C
Figure 6.
15
10
05
1 -50
-25
25
50
75
100
0 01
10
100
TC - Case Temperature - C
Figure 7.
Figure 8.
PRODUCT
4
INFORMATION
APRIL 1971 - REVISED SEPTEMBER 2002 Specifications are subject to change without notice.